Page Contents:
In this article, you will find information about the fuses of the Volkswagen Transporter / EuroVan / Caravelle (models 1991, 1992, 1993, 1994, 1995, and 1996), including diagrams of the fuse boxes, a list of fuses and relays, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in VW Transporter / EuroVan
Caution!
- A fuse with too high amperage could damage the electrical part and cause a fire. Do not use a fuse with a higher amperage than the fuse being replaced.
- To avoid damaging the electrical system, turn off all lights and accessories and remove the ignition key before replacing a fuse.
Location of the Fuse Box
Fuse Box Diagram
| № | A | Function |
|---|---|---|
| 1 | 10A (Red) | Left Headlight Low Beam |
| 2 | 10A (Red) | Riqht Headliqht Low Beam |
| 3 | 10A (Red) | Instrument & License Liqhts |
| 4 | 15A (Blue) | Rear Window Wiper/Washer, Heated Front Seats |
| 5 | 15A (Blue) | Windshield Wiper/Washer, Rear Window Washer, Heated Washer Jets |
| 6 | 30A (Green) | A/C, Fresh Air Fan |
| 7 | 10A (Red) | Riqht Tail Liqht & Side Marker Liqht, Enqine Compartment Lamp |
| 8 | 10A (Red) | Left Tailliqht & Side Marker Liqht |
| 9 | 20A (Yellow) | Rear Window & Mirror Heater |
| 10 | 15A (Blue) | Foq Lamps |
| 11 | 10A (Red) | Left Headliqht Hiqh Beam & Hiqh Beam Indicator |
| 12 | 10A (Red) | Riqht Headliqht Hiqh Beam |
| 13 | 10A (Red) | Horn, Radiator Coolinq Fan |
| 14 | 10A (Red) | Backup Liqhts, Electric Mirrors, Heated Front Seats, Windshield Washer Jets, Cruise Control, Power Roof |
| 15 | 10A (Red) | Enqine Electronics |
| 16 | 15A (Blue) | Warninq/Indicator Liqhts, Multi-Function Indicator, Glove Box Liqht, ABS |
| 17 | 10A (Red) | Turn Siqnals |
| 18 | 20A (Yellow) | Fuel Pump |
| 19 | 30A (Green) | A/C, Radiator Coolinq Fan |
| 20 | 10A (Red) | Brake Liqhts |
| 21 | 15A (Blue) | Dome & Luggaqe Lamps, Clock, Radio, Central Locking System, Multi-Function Indicator, Vanity Mirror, OBD Diagnostic |
| 22 | 10A (Red) | Cigarette Lighter |
| 1 | A/C Control Module Relay | |
| 2 | Rear Window Wiper/Washer Relay | |
| 3 | ECM Power Supply Relay | |
| 4 | Load Reduction Relay | |
| 5 | - | |
| 6 | Emergency Flasher Relay | |
| 7 | Headlight Washer Relay | |
| 8 | Washer/Wiper Intermittent Relay | |
| 9 | Seat Belt Warning Relay | |
| 10 | Fog Lamp/Parking Lamp Relay | |
| 11 | Dual Horn Relay | |
| 12 | Fuel Pump Relay | |
| 13 | Heater Control Module Relay | |
| 14 | Coolant Pump After-Run Relay | |
| 15 | - | |
| 16 | - | |
| 17 | - | |
| 18 | Roof Ventilator Fan Fuse | |
| 19 | Heater Air Blower Relay | |
| 20 | Starter Interlock/Back-up Light Relay | |
| 21 | 5A | Back-up Lights, Cruise Control |
| 22 | 20A | A/C (Second Evaporator) |
| 23 | Rear Window Defroster/Heated Mirror Relay | |
| 24 | 20A (Circuit Breaker) | Power Windows, Central Locking System |
| 25 | 10A | ABS System |
| 26 | 15A (Blue) | Rear Window Defroster, Heated Mirrors |
| 27 | A/C Compressor Clutch Relay | |
Additional Fuses
Located on left side of engine compartment, above battery:
- Radiator Fan – 50A
Located in the engine compartment, above the brake booster:
- Glow Plugs – 50A (1995 Diesel Models Only)
Located under drivers seat:
- Auxiliary HVAC Fan – 25A (Clear)
- Blower for Auxiliary Heater – 20A (Yellow)
- Refrigerator Socket, Socket below Folding Table – 30A (Green) (MV Camper Models Only)
- Fluorescent Light – 5A (Lt. Brown) (MV Camper Models Only)