Page Contents:
In this article, you will find information about the fuses of the Volkswagen Touareg (7L) (models 2002, 2003, 2004, 2005, and 2006), including diagrams of the fuse boxes, a list of fuses and relays, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in VW Touareg
Caution!
- A fuse with too high amperage could damage the electrical part and cause a fire. Do not use a fuse with a higher amperage than the fuse being replaced.
- To avoid damaging the electrical system, turn off all lights and accessories and remove the ignition key before replacing a fuse.
Engine Compartment Fuse Box
Fuse Box Diagrams
For engine codes BKW & BLE (4.9L V10 TDI Diesel)
| № | A | Function |
|---|---|---|
| S1 | 60A | Coolant Fan 1 |
| S2 | 30A | Coolant Fan 2 |
| S3 | 60A | Glow plugs 1 |
| S4 | 60A | Glow plugs 2 |
| S5 | - | - |
| S6 | 60A | Fuel Pump (FP), igntion system (only vehicles with second battery) |
| S7 | 10A | Fuel cooling, auxiliary coolant pump |
| S8 | 30A | Engine Control Module (ECM) 2 |
| S9 | 30A | Engine Control Module (ECM) 1 |
| S10 | 10A | A/C pressure sensor, EGR valve, Fuel Pump (FP)/ignition coil, coolant fan control modules |
| S11 | 15A | Thermostat for regulated engine cooling, A/C compressor regulation, engine oil temperature/level sender, turbocharger valves 1 and 2, intake manifold tuning vales 1 and 2 |
| S12 | 5A | Glow plug relays 1 and 2, Auxiliary Fuel Pump (FP), fuel cooling, brake switch |
| S13 | 15A | Fuel pump (FP) 1 |
| S14 | - | - |
| S15 | 10A | Power Supply Relay Terminal 30 |
| S16 | 10A | Parallel battery switch relay |
| S17 | 20A | Oxygen Sensor (O2S) - Diesel 1 and 2 |
| S18 | - | - |
| A1 | -J317- Power Supply (Terminal 30, B+) Relay (207) | |
| A2 | -J689- Power Supply Relay (Terminal 30, B+) Relay 2 (207) | |
| A3 | - | |
| A4 | -J52- Glow Plug Relay (202) | |
| A5 | -J496- Auxiliary Engine Coolant (EC) Pump Relay (404) | |
| A6 | -J445- Relay for pump, fuel cooling (404) | |
| B1 | - | |
| B2 | -J17- Fuel Pump (FP) Relay (53) | |
| B3 | -J495- Glow Plug Relay 2 (202) | |
| B4 | -J701- Power Supply Relay 1 (100) | |
| B5 | - | |
| B6 | - | |
| C19 | -J715- Fuel Pump (FP) Pre-run Relay (404) only with auxiliary heater | |
| C20 | -J682- Power Supply Relay (terminal 50) (433) | |
For engine code BAA (3.2L V6 Gasoline)
| № | A | Function |
|---|---|---|
| S1 | 60A | Coolant Fan 1 |
| S2 | 30A | Coolant Fan 2 |
| S3 | 40A | Secondary Air Injection (AIR) Pump Motor |
| S4 | - | - |
| S5 | - | - |
| S6 | - | - |
| S7 | 20A | Igntition Coils with Power Output Stage - Cyl. 1-3, Injectors - Cyl. 1-3 |
| S8 | 20A | Igntition Coils with Power Output Stage - Cyl. 4-6, Injectors - Cyl. 4-6 |
| S9 | 30A | Motoronic Engine Control Module (ECM), Valve 1 for camshaft adjustment, Camshaft Adjustment Valve 1 (exhaust), Intake Manifold Change-Over Valve |
| S10 | 10A | Leak Detection Pump (LDP), High Pressure Sensor (A/C), Evaporative Emission (EVAP) Canister Purge Solenoid Valve, Evaporative Emission (EVAP) Canister Purge Regulator Valve, Coolant FC (Fan Control) Control Module, Coolant FC (Fan Control) Control Module 2, Brake Booster Relay |
| S11 | 15A | A/C Compressor, Climatronic Control Module |
| S12 | 5A | Secondary Air Injection (AIR) Pump Relay, Coolant Circulation Pump Relay |
| S13 | 15A | Fuel Pump (FP) |
| S14 | 15A | Transfer Fuel Pump (FP) |
| S15 | 10A | Motronic Engine Control Module (ECM) Power Supply Relay, Motronic Engine Control Module (ECM) Power Supply Relay 2, Fuel Pump (FP) Relay, Fuel Pump (FP) 2 Relay |
| S16 | 30A | Coolant Circulation Pump Relay, Brake Booster Relay |
| S17 | 15A | Heated Oxygen Sensor (HO2S) (G39 & G108 - heating elements) |
| S18 | 7,5A | Heated Oxygen Sensor (HO2S) (G130 & G131 - heating elements) |
| A1 | -J670- Motronic Engine Control Module (ECM) Power Supply Relay 2 (53) | |
| A2 | - | |
| A3 | -J271- Motronic Engine Control Module (ECM) Power Supply Relay (167) | |
| A4 | -J299- Secondary Air Injection (AIR) Pump Relay (100) | |
| A5 | -J496- Auxiliary Engine Coolant (EC) Pump Relay (404) | |
| A6 | -J17- Fuel Pump (FP) Relay (404) | |
| B1 | - | |
| B2 | - | |
| B3 | - | |
| B4 | - | |
| B5 | - | |
| B6 | -J569- Brake Booster Relay (404) | |
| C19 | -J49- Fuel Pump (FP) 2 Relay (404) | |
| C20 | -J682- Power Supply Relay (terminal 50) (433) | |
For engine codes BHX & AXQ (4.2L V8 Gasoline)
| № | A | Function |
|---|---|---|
| S1 | 60A | Coolant Fan 1 |
| S2 | 30A | Coolant Fan 2 |
| S3 | 40A | Secondary Air Injection (AIR) Pump Motor |
| S4 | 40A | Secondary Air Injection (AIR) Pump Motor 2 |
| S5 | - | - |
| S6 | - | - |
| S7 | 20A | Igntition Coils with Power Output Stage - Cyl. 1-8 |
| S8 | 20A | Injectors - Cyl. 1-8 |
| S9 | 30A | Motoronic Engine Control Module (ECM), Intake Manifold Tuning (IMT) Valve 1, Valve 1 for camshaft adjustment, Valve 2 for camshaft adjustment, Intake Manifold Change-Over Valve |
| S10 | 10A | Leak Detection Pump (LDP), High Pressure Sensor (A/C), Evaporative Emission (EVAP) Canister Purge Solenoid Valve, Evaporative Emission (EVAP) Canister Purge Regulator Valve, Coolant FC (Fan Control) Control Module, Coolant FC (Fan Control) Control Module 2, Brake Booster Relay, Oil level Thermal Sensor, A/C Compressor Regulator Valve, Climatronic Control Module |
| S11 | 15A | Secondary Air Injection (AIR) Solenoid Valve |
| S12 | 5A | Secondary Air Injection (AIR) Pump Relay |
| S13 | 15A | Fuel Pump (FP) |
| S14 | 15A | Transfer Fuel Pump (FP) |
| S15 | 10A | Motronic Engine Control Modul (ECM), Motronic Engine Control Module (ECM) Power Supply Relay, Fuel Pump (FP) Relay, Fuel Pump (FP) 2 Relay |
| S16 | 30A | Brake Booster Relay, Brake System Vacuum Pump, Coolant Pump, Recirculation Pump (with auxiliiary heater only) |
| S17 | 15A | Heated Oxygen Sensor (HO2S) (G39 & G108 - heating elements) |
| S18 | 7,5A | Heated Oxygen Sensor (HO2S) (G130 & G131 - heating elements) |
| A1 | - | |
| A2 | - | |
| A3 | -J271- Motronic Engine Control Module (ECM) Power Supply Relay (614) | |
| A4 | -J299- Secondary Air Injection (AIR) Pump Relay (100) | |
| A5 | -J496- Auxiliary Engine Coolant (EC) Pump Relay (404) | |
| A6 | -J49- Fuel Pump (FP) 2 Relay (404) | |
| B1 | - | |
| B2 | - | |
| B3 | -J545- Secondary Air Injection (AIR) Pump Relay 2 (100) | |
| B4 | - | |
| B5 | - | |
| B6 | -J569- Brake Booster Relay (404) | |
| C19 | -J17- Fuel Pump (FP) Relay (404) | |
| C20 | -J682- Power Supply Relay (terminal 50) (433) | |
Main Fuse Box (Fuse Holder D)
Located under driver’s seat.
| № | A | Function |
|---|---|---|
| SD1 | 150A | Fuse for Left instrument panel fuse box |
| SD2 | 150A | Fuse for Right instrument panel fuse box |
| SD3 | 60A | Fuse for Right instrument panel fuse box |
| SD4 | 60A | Fuse for E-Box |
| SD5 | 60A | Fuse for voltage supply Terminal 15 relay |
| SD7 | 250A | Fuse for second battery charge relay |
| SD8 | 150A | Fuse for E-Box |
| SD9 | 5A | Fuse for vehicle electrical equipment control module |
| SD10 | 10A | Fuse for vehicle electrical equipment control module |
| SD11 | 5A | Fuse for starter circuit diagnostics |
| SD12 | - | - |
| SD13 | 40A | Fuse for relay - air suspension |
| SD14 | - | - |
| 1 | -E74- Main Battery Switch (with reset) | |
| 2 | -J329- Voltage Supply Terminal 15 (B+) Relay (433, 100), where applicable | |
| 3 | -J713- Second Battery Charge Relay |
Parallel Battery Connection Relay -J581-
Located near second battery in luggage compartment (where applicble).
Left-Side Instrument Panel Fuse Box
Fuse Box Diagram (Fuse Panel B)
| № | A | Function |
|---|---|---|
| SB1 | 20A | Cigarette lighter - front |
| SB2 | 5A | Auxiliary heater - timer (where applcable) |
| SB3 | 20A | 12V Outlet (footwell), 12V Outlet (center console, front) |
| SB4 | 15A | Auxiliary heater (where applicable) |
| SB5 | 20A | 12V Outlet - center console, rear, cigarette lighter -rear |
| SB6 | 15A | Access/start control module |
| SB7 | 5A | Data Link Connector (DLC), Antenna switch |
| SB8 | 30A | Wiper motor |
| SB9 | 15A | Vehicle electrical system control module - Windshield washer pump |
| SB10 | 25A | Left rear window lifter |
| SB11 | 15A | Door control modules - Central Locking System (left rear & left front) |
| SB12 | 20A | Vehicle electrical system control module - Interior lights |
| SB13 | - | - |
| SB14 | 25A | Left front window lifter |
| SB15 | 15A | Central control module for comfort system - Left tail lamps |
| SB16 | 20A | Vehicle electrical system control module - Horns |
| SB17 | 10A | Vehicle electrical system control module - Left parking lamps, turn signals |
| SB18 | 20A | Headlamp washer pump |
| SB19 | 15A | Vehicle electrical system control module - Fog lamps |
| SB20 | 30A | Power seats |
| SB21 | 15A | Vehicle electrical system control module |
| SB22 | 30A | Differential lock control module |
| SB23 | 10A | Differential lock control module |
| SB24 | 5A | Tire pressure monitoring control module |
| SB25 | 15A | Power steering column adjustment |
| SB26 | 10A | Airbag control module, Motronic Engine Control Module (ECM), instrument cluster, brake/clutch switches, ESR Mass Air Flow (MAF) Sensor |
| SB27 | - | - |
| SB28 | 5A | Brake light disable realy, brake switch (where applicable) |
| SB29 | - | - |
| SB30 | - | - |
| SB31 | - | - |
| SB32 | - | - |
| SB33 | 5A | Steering column electronic systems control module |
| SB34 | 5A | Alarm system (sensor), heated seat relay |
| SB35 | 15A | Vehicle electrical system control module -Headlamps (high/low beam) |
| SB36 | 10A | Vehicle electrical system control module |
| SB37 | - | - |
| SB38 | 10A | Brake light switch |
| SB39 | 5A | Manual A/C, Power supply relay, instrument cluster, rear window defogger relay, heated seat relay |
| SB40 | 5A | Instrument cluster |
| SB41 | 15A | Access/start control module |
| SB42 | 30A | Power sunroof |
| SB43 | - | - |
| SB44 | 30A | Power steering column adjustment, power seats, power seats (with memory) control module |
| SB45 | 30A | Left front power seat, rear seat heating control modules |
| SB46 | - | - |
| SB47 | 10A | Differential lock control module |
| SB48 | 5A | Auxiliary heater (where applicable) |
| SB49 | 5A | Servotronic control module |
| SB50 | 10A | Positive Crankcase Ventilation (PCV) Heating Element, Secondary Air Injection (AIR) Solenoid valve |
| SB51 | 5A | Air quality sensor, seat heaters, electronic parking brake |
| SB52 | 30A | Rear wiper motor |
| SB53 | 5A | Mirror heating, light switch, steering column electronics control module |
| SB54 | 10A | Headlamp range control |
| SB55 | 15A | Auxiliary heater relay (where applcable) |
| SB56 | 40A | Blower - Climatronic 2-Zone |
| SB57 | 40A | Rear blower - Climatronic 4-Zone |
Right-Side Instrument Panel Fuse Box
Fuse Box Diagram (Fuse Panel C)
| № | A | Function |
|---|---|---|
| SC1 | 15A | Trailer wiring, control module for towing sensor (where applicable) |
| SC2 | 5A | Control module for parking aid |
| SC3 | 15A | Control module for towing sensor (where applicable) |
| SC4 | 5A | Telematics, telephone (where applicable) |
| SC5 | 15A | Control module for towing sensor (where applicable) |
| SC6 | 30A | ABS control module (w/EDL) |
| SC7 | 5A | Differential control module |
| SC8 | 20A | Vehicle electrical system control module - Lamps |
| SC9 | 5A | CD-Changer |
| SC10 | 5A | TV-Tuner (where applicable) |
| SC11 | 10A | Radio |
| SC12 | 20A | Amplifier, antenna switch |
| SC13 | - | - |
| SC14 | 15A | Central control module for comfort system - Right tail lamps |
| SC15 | 25A | Right rear window lifter |
| SC16 | 10A | Luggage compartment lamps |
| SC17 | 15A | Vehicle electrical system control module - Headlamps (high/low beam) |
| SC18 | 30A | Rear window defogger relay |
| SC19 | - | - |
| SC20 | - | - |
| SC21 | 10A | Alarm horn, spare tire unlock |
| SC22 | 30A | Right front power seat, front heated seat control modules |
| SC23 | 10A | Climatronic control module |
| SC24 | 30A | Passenger memory seat control module |
| SC25 | 5A | Rear A/C control head (Climatronic) |
| SC26 | - | - |
| SC27 | 15A | Level control system control module |
| SC28 | 10A | - |
| SC29 | 10A | Transmission Control Module (TCM) |
| SC30 | 20A | Closing assist relay |
| SC31 | 15A | Central control module for comfort system |
| SC32 | 10A | Door control modules - Central Locking System (right rear & right front) |
| SC33 | - | - |
| SC34 | 25A | Right front window lifter |
| SC35 | 10A | Vehicle electrical system control module - Right parking lamps, turn signals |
| SC36 | 5A | Roof module, telephone, compass (where applicable) |
| SC37 | - | - |
| SC38 | 10A | ABS control module (w/EDL) |
| SC39 | - | - |
| SC40 | 10A | Differential control module |
| SC41 | 10A | Control module for towing sensor (where applicable) |
| SC42 | 5A | Garage door opener control module, garage door opener indicator lamp |
| SC43 | 5A | Back-Up light switch |
| SC44 | 5A | Heated washer nozzles, level control system control head |
| SC45 | - | - |
| SC46 | - | - |
| SC47 | - | - |
| SC48 | 10A | Level control system control module |
| SC49 | 5A | Power mirrors, telematics, telephone (where applicable) |
| SC50 | 5A | Control module for parking aid |
| SC51 | 20A | Transmission Control Module (TCM) |
| SC52 | 5A | Tiptronic switch, Multi-Function Transmission Range (TR) Switch, selector lever park position solenoid |
| SC53 | - | - |
| SC54 | - | - |
| SC55 | - | - |
| SC56 | 40A | ABS control module (w/EDL) |
| SC57 | 40A | Differential control module |
Electronics Box
Located behind instrument panel (left)
Not all Relays listed here are applicable to USA/CDN market.
| № | Function |
|---|---|
| D1 | -J236- Servotronic Control Module (463) |
| D2 | -J714- Closing Assist Relay (404) |
| D3 | -J403- Relay for compressor level control system (214) |
| D4 | - |
| D5 | -J329- Voltage Supply Terminal 15 (B+) Relay (433) |
| D6 | -J493- Additional Water Heater Relay (404) |
| D7 | -J9- Rear Window Defogger Relay (53) |
| D8 | -J83- Heated Seat Relay (404) to 01.03 |
| D9 | -J419- Auxiliary relay for brake light (444) |
| E1 | -J309- Solar Cell Separation Relay (79) |
| E2 | -J732- Spare Tire Unlock Relay (404) |
| E3 | -J32- A/C Relay (53) |
| E4 | -J160- recirculation Pump Relay (404) |
| E5 | - |
| E6 | - |
| E7 | -J39- Relay for headlamp cleaning system (53) |
| E8 | -J708- Residual Heat Relay (404) (engine codes BAA & BHX only) |
| E9 | - |