Page Contents:
In this article, you will find information about the fuses of the Volkswagen Crafter (models 2006, 2007, 2008, 2009, 2010, and 2011), including diagrams of the fuse boxes, a list of fuses and relays, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in VW Crafter
Caution!
Using unsuitable fuses, repairing fuses, and bridging a power circuit without fuses can causes fires and serious injuries.
- Never install fuses that have a higher amp rating.
- Replace fuses only with fuses of same rating and size. Make sure that the color and label are identical to the faulty fuse.
- Never repair fuses.
- Never use metal strips, paper clips or similar objects as substitutes for fuses.
Location of Fuse Boxes
- Terminal 30 voltage supply fuse (-S190-), in the line section between the alternator and the starter.
- Fuse holder A – on the battery.
- Fuse holder B – on left A-pillar.
- Fuse holder C – on left A-pillar.
- Fuse holder D – under driver seat.
- Single fuses under driver seat (fuses for special vehicles).
Fuse Box Diagrams
Fuse Holder A
| № | A | Function/component |
|---|---|---|
| SA1 | 80A | Automatic glow period control unit -J179- |
| SA2 | 40A 60A 80A | Radiatorfan control unit-J293- (only on models with A/C system) Radiator fan -V7- (only on models with A/C system) Right radiator fan -V35- (only on models with air conditioning system) |
| SA3 | 80A | Onboard supply control unit -J519- Engine component current supply relay -J757- Fuse holder C: SC2, SC3, SC8-SC10, SC16 |
| SA4 | 150A | Auxiliary battery -A1- Tipping mechanism fuse -S186- (before August 2006) Fuse 1 (30) -S204- (after July 2006) Fuse 2 (30) -S205- (after September 2006) Main fuse for multiple equipment configurations -S245- (before August 2006) Fuse holder D: SD23-SD25, SD28 (after September 2006 on models with second battery) |
| SA5 | 150A | Terminal 15 voltage supply relay -J329- Horn relay -J413- Onboard supply control unit -J519- Terminal 15 voltage supply relay 2 -J681- Fuse holder B: SB1-SB18 Fuse holder C: SC4-SC7, SC11-SC15, SC17-SC25 |
| 6 | Terminal 15 relief relay -J404- Relief relay 2 for terminal 15 -J817- (only for models in the 3.8 t weight class) Fuse for heated front windscreen -S127- Fuse 1 (30) -S204- (before June 2006) Fuse holder D: SD10-SD33, SD42 | |
| SA7 | 150A | Auxiliary air heater element -Z35- |
Fuse Holder B
| № | A | Function/component |
|---|---|---|
| 1 | 25A | Driver door control unit -J386- |
| 2 | 10A | Diagnostic connection -U31- |
| 3 | 25A | ABS control unit -J104- |
| 4 | 40A | ABS control unit -J104- |
| 5 | - | - |
| 6 | 7.5A | Evaluation unit for reducing agent level -G698- (from November 2008 to May 2009) Reverse flow valve for reducing agent -N473- (from November 2008 to May 2009) Pump for reducing agents -V437- (from November 2008 to May 2009) |
| 7 | 30A | Headlight washer system pump -V11- |
| 8 | 15A | Rotating light and siren system switch -E11- (from July 2006) Switch for rotating light -E162- (from July 2006) Alarm horn -H12- Alarm system relay 1 -J460- Siren system relay 2 -J645- (From July 2006) |
| 9 | 10A | Turn signal relay for roof mounted turn signals -J436- (from May 2007) |
| 10 | 15A | Radio -R- Control unit with display for radio and navigation -J503- |
| 11 | 7.5A | Mobile telephone operating electronics control unit -J412- Tachograph control unit -J621- |
| 12 | 30A | Heater/heat output switch -E16- Fresh air blower relay -J13- Fresh air blower control unit -J126- Fresh air blower -V2- |
| 13 | 7.5A | Pre-selection clock -E111- Remote control receiver for auxiliary coolant heater -R149- |
| 14 | 30A | Operating unit for centre dash panel -J819- |
| 15 | 10A | Load area illumination switch -E481- (to October 2008) |
| 16 | 10A | Heater/heat output switch -E16- A/C control module -J301- CD changer -R41- |
| 17 | 10A | Interior illumination switch -E599- |
| 18 | - | - |
Fuse Holder C
| № | A | Function / component |
|---|---|---|
| 1 | 15A | Treble horn -H2- |
| 2 | 25A | Electronic ignition lock -D9- El. steer, col. lock CU -J764- |
| 3 | 10A | Electronic ignition lock -D9- Control unit in dash panel insert -J285- |
| 4 | 5A | Light switch -E1- Operating unit for centre dash panel -J819- |
| 5 | 30A | Windscreen wiper motor -V- |
| 6 | 15A | Fuel system pressurisation pump -G6- |
| 7 | 5A | Steering column electronics control unit -J527- |
| 8 | 20A | Engine control unit -J623- |
| 9 | 20A/25A | Fuse 6 on fuse holder B -SB6- (from November 2008 to May 2009) Fuse holder D: SD34-SD36 (from May 2009) |
| 10 | 10A | Fuel pressure regulating valve -N276- |
| 11 | 15A | Relief relay 2 for terminal 15 -J817- (only for models in the 3.8 t weight class) Fuse 1 on fuse holder D -SD1- Fuse 2 on fuse holder D -SD2- |
| 12 | 10A | Airbag control unit -J234- |
| 13 | 15A | Glove compartment light switch -E26- Cigarette lighter -U1- |
| 14 | 5A | Light switch -E1- Control unit in dash panel insert -J285- Diagnostic connection -U31- |
| 15 | 5A | Heater/heat output switch -E16- Headlight range control regulator -E102- Left headlight range control motor -V48- Right headlight range control motor -V49- |
| 16 | 10A | Main switch for stop/start system -E101- Gearbox neutral position switch -F365- Oil level and oil temperature sender -G266- Fuel pump relay -J17- Continued coolant circulation relay -J151- Automatic glow period control unit -J179- Terminal 50 voltage supply relay -J682- Charge pressure control solenoid valve -N75- Coolant circuit valve -N214- Fuel metering valve -N290- Exhaust gas recirculation cooler changeover valve -N345- Lambda probe heater -Z19- |
| 17 | 10A | Airbag control unit -J234- |
| 18 | 7.5A | Brake light switch -F- (from July 2006) Brake pedal switch -F63- (from July 2006) Relief relay for terminal 15 -J404- |
| 19 | 7.5A | Onboard supply control unit -J519- (Interior light) |
| 20 | 25A | Onboard supply control unit -J519- |
| 21 | 5A | Air mass meter -G70- Engine control unit -J623- |
| 22 | 5A | Brake light switch -F- (before June 2006) Brake pedal switch -F63- (before June 2006) Lateral acceleration sensor -G200- (from July 2006) Longitudinal acceleration sensor -G251- (from July 2006) ABS control unit -J104- (From July 2006) |
| 23 | 25A | Starter -B- Onboard supply control unit -J519- |
| 24 | 10A | Reserve Kl. 15- |
| 25 | 30A | 12-V socket -U5- |
| R1 | Horn relay -J413- | |
| R2 | Wiper motor switch-over relay 2 -J369- | |
| R3 | Fuel pump relay -J17- | |
| R4 | Wiper motor switch-over relay 1 -J368- | |
| R5 | Terminal 50 voltage supply relay -J682- | |
| R6 | Terminal 15 voltage supply relay -J329- | |
| R7 | Engine component current supply relay -J757- | |
| R8 | Terminal 15 voltage supply relay 2 -J681- |
Fuse Holder D
| № | A | Function / component |
|---|---|---|
| 1 | 5A | Operating unit for window regulator in driver door -E512- Heated rear window relay -J9- (before June 2006) Relay 2 for heated rear window -J868- (From July 2006) |
| 2 | 30A | Rear left wing door window wiper motor -V92- Rear window wiper motor in right wing door -V93- |
| 3 | 5A | Pre-selection clock -E111- Gearbox neutral position switch -F365- Display unit control unit -J146- Mobile telephone operating electronics control unit -J412- Reversing camera -R189- |
| 4 | 7.5A | Working speed control switch -E261-(from July 2006) Power take-off warning switch -F247- (from July 2006) Relay for heated rear window -J9- (until June 2006) Trailer detector control unit -J345- Tachograph control unit -J621- (From July 2006) |
| 5 | 5A/10A | Selector lever -E313- Automated manual gearbox control unit -J514- |
| 6 | 5A | Battery regulation control unit -J840- (until May 2013) Heater element for crankcase breather -N79- |
| 7 | 10A | Fuel filter heater -Z57- |
| 8 | 5A/10A | Tilting mechanism button -E223- Relay for special constructions, terminal 15 -J821- 6-pin connector -T6ah- (from May 2007) 7-pin connector -T7f- (Tail lift coupling point) |
| 9 | 15A | Switch for roof ventilator to ventilate loading area -E534- Siren system relay -J408- |
| 10 | 25A | Interface for external use |
| 11 | 15A | Relay for special constructions, terminal 15 -J821- |
| 12 | 10A | Relay for special constructions, terminal 61 -J822- |
| 13 | 30A/10A | Evaporator blower control unit -J349- (from May 2007 to May 2011) Turn signal relay for roof mounted turn signals -J436- (To May 2007) |
| 14 | 20A | Trailer detector control unit -J345- (Before August 2006) 9-pin connector -T9b- (Preliminary setup for trailer attachment from September 2006) Trailer socket -U10- (From September 2006) |
| 15 | 25A | Trailer detector control unit -J345- |
| 16 | 7.5A | Parking aid control unit -J446- Tyre Pressure Monitoring System control unit -J502- |
| 17 | 25A | Control unit for programmable special functions -J820- |
| 18 | 25A | Control unit for programmable special functions -J820- |
| 19 | 5A/25A | Roof electronics control unit -J528- |
| 20 | 7.5A/10A | Continued coolant circulation relay -J151- Entry and footwell light relay -J348- (from May 2009) |
| 21 | 15A/30A | Heated rear window relay -J9- |
| 22 | 15A | Heated rear window relay -J9- (before June 2006) Relay 2 for heated rear window -J868- |
| 23 | 10A/15A | Load area illumination switch -E481- (after November 2008) 12 V socket 2 -U18- |
| 24 | 15A | 12 V socket 4 -U20- |
| 25 | 15A | 12 V socket 3 -U19- |
| 26 | 25A | Auxiliary heater control module -J364- |
| 27 | 20A/25A | Auxiliary heater control module -J364- Control unit 2 for supplementary heating -J824- |
| 28 | 30A/40A | Evaporator blower control unit -J349- (before April 2007) Gearbox hydraulic pump relay -J510- (from May 2007) |
| 29 | 15A | Automated manual gearbox control unit -J514- |
| 30 | 40A | Gearbox hydraulic pump relay -J510- (before April 2007) Battery regulation control unit -J840- |
| 31 | 30A/15A | Rear fresh air blower control unit -J391- Left sliding door control unit -J558- Rear fresh air blower -V80- |
| 32 | 5A | Battery monitoring control unit -J367- |
| 33 | 15A | Right sliding door control unit -J731- |
| 34 | 15A | Control unit for reducing-agent heater -J891- (from April 2009) |
| 35 | 15A/3A | Control unit for reducing-agent heater -J891- (from April 2009) |
| 36 | - | - |
| R11 | Relay for special constructions, terminal 15 -J821- | |
| R21 | Relay for special constructions, terminal 61 -J822- | |
| R31 | Interior light relay -J602- Relay for tail lift -J823- Tipping mechanism relay -J432- (to October 2007) | |
| R41 | Headlight washer system relay -J39- | |
| R51 | Rotating light relay -J326- | |
| R61 | Alarm system relay 1 -J460- | |
| R71 | Coolant pump relay -J235- | |
| R81 | Continued coolant circulation relay -J151- | |
| R91 | Siren system relay -J408- | |
| R101 | - | |
| *1) Until April 2009 | ||
Relay carrier in driver’s seat storage compartment
Until April 2009
| № | Relay |
|---|---|
| 1 | Terminal 15 relief relay -J404- |
| 2 | Heated rear window relay -J9- |
| 3 | Relief relay 2 for terminal 15 -J817- |
| 4 | - |
| 5 | Heated windscreen relay -J47- |
| 6 | Heated rear window relay 2 -J868- |
| 7 | Fresh air blower relay -J13- (Auxiliary coolant heater with independent vehicle heater) |
| 8 | Gearbox hydraulic pump relay -J510- (with Shiftmatic only) |
| 9 | - |
| 10 | - |
| 11 | - |
| 12 | - |
| 13 | - |
| 14 | - |
| A | Battery isolator relay -J7- |
After April 2009
| № | Relay |
|---|---|
| 1 | - |
| 2 | Terminal 15 relief relay -J404- |
| 3 | Relief relay 3 for terminal 15 -J896- Relay for compressed air compressor -J1014-1 |
| 4 | Gearbox hydraulic pump relay -J510- Daytime running light switch-on relay -J90-1 |
| 5 | Heated rear window relay -J9- |
| 6 | Heated rear window relay 2 -J868- |
| 7 | Relief relay 2 for terminal 15 -J817- |
| 8 | - |
| 9 | Heated windscreen relay -J47- |
| 10 | Fresh air blower relay -J13- |
| 11 | - |
| 12 | - |
| 13 | - |
| 14 | - |
| 15 | Relay for special constructions, terminal 15 -J821- |
| 16 | Relay for special constructions, terminal 61 -J822- |
| 17 | Relay for tail lift -J823- Interior light relay -J602- |
| 18 | Headlight washer system relay -J39- Relay for compressed air compressor release -J1009-1 |
| 19 | Siren system relay 2 -J645- Relay for compressed air compressor regeneration -J1008-1 |
| 20 | Alarm system relay 1 -J460- |
| 21 | Coolant pump relay -J235- |
| 22 | Continued coolant circulation relay -J151- Entry and footwell light relay -J348- (from May 2009) |
| 23 | Siren system relay -J408- ABS switch-off relay -J149-1 |
| 24 | Transfer box lockout relay 1 -J1012- |
| 25 | Transfer box lockout relay 2 -J1011- |
| 26 | Transfer box lockout relay 3 -J1010- |
| A | Battery isolator relay -J7- |
| *1) Position depends on the equipment package | |