Page Contents:
In this article, you will find information about the fuses of the Toyota Hilux (models 2011, 2012, 2013, 2014, and 2015), including diagrams of the fuse boxes, a list of fuses, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in Toyota Hilux
If any of the electrical components do not operate, a fuse may have blown. If this happens, check and replace the fuses as necessary. Replace the blown fuse with a new fuse of an appropriate amperage rating. The amperage rating can be found on the fuse box lid.
Caution!
- Never use a fuse of a higher amperage rating than that indicated, or use any other object in place of a fuse.
- Always use a genuine Toyota fuse or equivalent. Never replace a fuse with a wire, even as a temporary fix. This can cause extensive damage or even fire.
- Do not modify the fuses or fuse boxes.
Location of Fuse Boxes
Engine Compartment
Push the tab in and lift the lid off.
Passenger Compartment
Left-hand drive vehicles
Right-hand drive vehicles
- Driver’s side instrument panel access: Remove the lower instrument panel.
- Passenger’s side instrument panel access: Open the glove box. Push in each side of the glove box to disconnect the claws.
Fuse Box Diagrams
Engine Compartment Fuse Box
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | SPARE | 25A | Spare fuse |
| 2 | SPARE | 15A | Spare fuse |
| 3 | SPARE | 10A | Spare fuse |
| 4 | FOG | 7.5A | Front fog lights |
| 5 | HORN | 10A | Horn |
| 6 | EFI | 25A | Multiport fuel injection system / sequential multiport fuel injection system |
| 7 | PTC NO.1 | 50A | Power heater |
| 8 | PWR SEAT | 30A | Power seat |
| 9 | PTC NO.2 | 50A | Power heater |
| 10 | H-LP CLN | 40A | Headlight cleaners |
| 11 | FR HTR | 50A | Air conditioning system, A/C |
| 12 | ABS NO.2 | 30A | ABS, TRC, VSC |
| 13 | ABS NO.1 | 40A | ABS, TRC, VSC |
| 14 | ALT | 100A | Charging system, PWR SEAT, RR CLR, H-LP CLN, FR HTR, AM1, IG1, PTC NO.1, PTC NO.2, PWR OUT, STOP, TAIL, OBD |
| 15 | GLOW | 80A | Engine glow system |
| 16 | BATT P/l | 50A | FOG, HORN, EFI |
| 17 | AM2 | 30A | Engine starter, ST, IGN, INJ, MET |
| 18 | MAIN | 40A | H-LP RH, H-LP LH, H-LP RL, H-LP LL |
| 19 | A/PUMP | 50A | Emission control system |
| 20 | H-LP RL | 15A | Right-hand headlight (low beam) |
| 21 | H-LP LL | 15A | Left-hand headlight (low beam) |
| 22 | H-LP RH | 15A | Right-hand headlight (high beam), right-hand headlight (low beam) |
| 23 | H-LP LH | 15A | Left-hand headlight (high beam), left-hand headlight (low beam) |
| 24 | EFI NO.2 | 10A | Multiport fuel injection system / sequential multiport fuel injection system |
| 25 | ECU-IG-NO.2 | 10A | Charging system, air conditioning system, ABS, VSC, headlight cleaners |
| 26 | ECU-B | 10A | Door courtesy switches, power door lock system, wireless remote control system, steering sensor, headlights |
| 27 | RAD | 20A | Audio system |
| 28 | DOME | 7.5A | Interior lights, engine switch light, personal light, gauges and meters, clock, multi-information display, wireless remote control system, daytime running light system, fog light |
| 29 | A/F | 20A | Emission control system |
| 30 | ETCS | 10A | Multiport fuel injection system / sequential multiport fuel injection system |
| 31 | ALT-S | 7.5A | Charging system |
| 32 | TURN-HAZ | 15A | Emergency flashers and turn signal lights |
| 33 | SIREN | 7.5A | SIREN |
| 34 | ECU-B NO.2 | 7.5A | Air conditioning system |
| 35 | DCC | 30A | ECU-B, DOME, RAD |
Driver’s side instrument panel fuse box
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | PWR OUT | 15A | Power outlet |
| 2 | TAIL | 10A | Instrument panel light, front fog lights, manual headlight leveling dial, front position lights, tail lights, license plate lights, multiport fuel injection system / sequential multiport fuel injection system, multiinformation display, daytime running light system, automatic headlight system |
| 3 | STOP | 10A | Stop lights, high mounted stoplight, multi-port fuel injection system / sequential multiport fuel injection system, ABS, TRC, VSC, shift lock control system |
| 4 | OBD | 7.5A | On-board diagnosis system |
| 5 | INJ | 15A | Multiport fuel injection system/sequential multiport fuel injection system |
| 6 | ECU-IG & GAUGE | 10A | Air conditioning system, charging system, rear differential lock system, ABS, TRC, VSC, emergency flashers, turn signal lights, back-up lights, multiport fuel injection system / sequential multiport fuel injection system, shift lock control system, rear window defogger, headlights, door courtesy switches, power door lock system, wireless remote control system, steering sensor, daytime running light system, cruise control, headlight cleaners, seat heaters, outside rear view mirror defoggers, multi-information display, passenger’s seat belt reminder light |
| 7 | WIP | 20A | Windshield wiper and washer |
| 8 | IGN | 7.5A | Multiport fuel injection system / sequential multiport fuel injection system, SRS airbags, fuel pump |
| 9 | ACC | 7.5A | Audio system, power outlet, clock, power rear view mirror control system, shift lock control system, multi-information display |
| 10 | CIG | 15A | Cigarette lighter |
| 11 | MET | 7.5A | Gauges and meters, DPF system |
| 12 | A/C | 10A | Air conditioning system |
| 13 | ST | 7.5A | Starting system, gauges and meters, multiport fuel injection system / sequential multiport fuel injection system |
Rear side
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | AM1 | 40A | Rear differential lock system, ABS, TRC, VSC, ACC, CIG, ECU-IG & GAUGE, WIP |
| 2 | IG1 | 40A | PWR, S-HTR, 4WD, DOOR, DEF, MIR HTR |
Passenger’s side instrument panel fuse box
| № | Fuse | A | Circuit |
|---|---|---|---|
| 1 | MIR-HTR | 15A | Outside rear view mirror defoggers |
| 2 | 4WD | 20A | Rear differential lock system, ABS, TRC, VSC |
| 3 | S-HTR | 15A | Seat heaters |
| 4 | DEF | 20A | Rear window defogger, multiport fuel injection system / sequential multiport fuel injection system |
| 5 | DOOR | 25A | Power door lock system, power windows |
| 6 | PWR | 30A | Power windows |