Page Contents:
In this article, you will find information about the fuses of the Ford Taurus (models 2004, 2005, 2006, and 2007), including diagrams of the fuse boxes, a list of fuses and relays, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in Ford Taurus
If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
Caution!
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Always disconnect the battery before servicing high current fuses.
- To reduce risk of electrical shock, always replace the cover to the Power Distribution Box before reconnecting the battery or refilling fluid reservoirs.
Location of Fuse Boxes
Passenger Compartment Fuse Panel:
The fuse panel is located below and to the left of the steering wheel by the brake pedal. Remove the panel cover to access the fuses.
Power Distribution Box:
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
Relays:
Relays are located in the power distribution box and should be replaced by qualified technicians.
Fuse Box Diagrams
2004
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | - | Accessory delay relay |
| 2 | - | Driver one touch down relay |
| 3 | - | Blower motor relay |
| 4 | - | Flasher relay |
| 5 | - | Not used |
| 6 | - | Not used |
| 7 | 20A | Rear defrost grid feed (wagon only)/Rear defrost relay coil feed (sedan only) |
| 8 | 40A | Blower motor |
| 9 | - | Rear defrost relay |
| 10 | 30A CB | Power seats, Delayed accessory, Adjustable pedais |
| 11 | 10A | Right headlamp |
| 12 | 15A | Highbeam headlamps |
| 13 | - | Not used |
| 14 | - | Not used |
| 15 | 10A | Left headlamp |
| 16 | 10A | Not used (spare) |
| 17 | 15A | Stop lamp, Speed control deactivation switch |
| 18 | 15A | Parklamps, PWM (backlighting), Autolamps |
| 19 | 10A | Heated mirrors, Rear defrost switch indicator |
| 20 | 10A | Restraints (air bag module/OCS module) |
| 21 | 15A | Transmission range sensor (transmission position switch) |
| 22 | 15A | Front washer pump, Electrochromatic mirror, Compass, Cluster (RUN/ACC), Integrated Control Panel (ICP) logic, Rear wiper (wagon only), Rear washer (wagon only) |
| 23 | 30A | Front wiper motor |
| 24 | - | Not used |
| 25 | 20A | Power point |
| 26 | 20A | Power locks, Liftgate (wagon)/Trunk (sedan) release |
| 27 | 10A | Anti-lock Brake System (ABS), Speed control, Traction control, Brake-shift interlock, A/C function switch (manual A/C only), Temperature blend door (manual A/C only), Defrost coil |
| 28 | 15A | Turn signals, Back-up lamps |
| 29 | 20A | Cigar lighter |
| 30 | 10A | Courtesy lighting, Battery saver, Power mirrors, Decklid lamp, Power antenna (wagon only), Pulse stretching module (wagon only) |
| 31 | 10A | Blower motor relay coil, Puddle lamp relay coil, Electronic Automatic Temperature Control (EATC) logic |
| 32 | 10A | Cluster, Flex fuel module, ICP logic, Passive anti-theft module (GEM power) |
| 33 | 15A | Hazard flasher, Cluster power, ICP power, EATC |
| 34 | 5A | GEM logic |
| 35 | 10A | Backlighting |
| 36 | 2A | Powertrain Control Module (PCM) relay, Fuel pump relay, A/C clutch |
| 37 | 25A | Autolamp, Daytime Running Lamps (DRL), Flash-to-pass, Headlamp switch |
| 38 | 15A | Horn, Diagnostic connector (OBD II) |
| 39 | - | Not used |
| 40 | - | Not used |
| 41 | - | Not used |
| 42 | - | Not used |
| CB - Circuit Breaker | ||
Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 60A** | Fuse junction panel |
| 2 | 30A** | Powertrain Control Module (PCM) |
| 3 | 60A** | Fuse junction panel |
| 4 | 10A CB | Low speed cooling fan |
| 5 | 40A** | Cooling fan |
| 6 | - | Not used |
| 7 | 40A** | Starter relay, Ignition switch |
| 8 | - | Not used |
| 9 | 20A** | Cooling fan (passenger side) |
| 10 | 20A** | Cooling fan (driver side) |
| 11 | 50A** | Rear defrost (sedan only) |
| 12 | - | Not used |
| 13 | 40A** | Anti-lock Brake System (ABS) module pump feed |
| 14 | - | Not used |
| 15 | 20A* | ABS module valve solenoid |
| 16 | 20A* | Fuel pump relay |
| 17 | 20A* | CD |
| 18 | 10A* | A/C clutch relay, PCM keep alive power |
| 19 | - | Not used |
| 20 | - | Not used |
| 21 | - | Not used |
| 22 | 5A* | Heated PCV valve |
| 23 | - | Starter motor relay |
| 24 | - | Fan relay |
| 25 | - | Wiper speed relay |
| 26 | 10A* | Alternator |
| 27 | 5A* | Rear control unit, Antenna |
| 28 | 15A* | HEGO sensor, Transmission shift solenoid, Canister vent, A/C clutch relay |
| 29 | - | Wiper park relay |
| 30 | - | Fuel pump relay |
| 31 | - | PCM power relay |
| 32 | - | Fan relay |
| 33 | - | A/C clutch relay |
| *Mini Fuses **Maxi Fuses CB - Circuit breaker | ||
2005
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | - | Accessory delay relay |
| 2 | - | Driver one touch down relay |
| 3 | - | Blower motor relay |
| 4 | - | Flasher relay |
| 5 | - | Not used |
| 6 | - | Not used |
| 7 | 20A | Rear defrost grid feed (wagon only)/Rear defrost relay coil feed (sedan only) |
| 8 | 40A | Blower motor |
| 9 | - | Rear defrost relay |
| 10 | 30A CB | Power seats, Delayed accessory |
| 11 | 10A | Right headlamp |
| 12 | 15A | Highbeam headlamps |
| 13 | - | Not used |
| 14 | - | Not used |
| 15 | 10A | Left headlamp |
| 16 | 10A | Not used (spare) |
| 17 | 15A | Stop lamp, Speed control deactivation switch |
| 18 | 15A | Parklamps, PWM (backlighting), Autolamps |
| 19 | 10A | Heated mirrors, Rear defrost switch indicator |
| 20 | 10A | Restraints (air bag module/OCS module) |
| 21 | 15A | Transmission range sensor (transmission position switch) |
| 22 | 15A | Front washer pump, Electrochromatic mirror, Compass, Cluster (RUN/ACC), Integrated Control Panel (ICP) logic, Rear wiper (wagon only), Rear washer (wagon only) |
| 23 | 30A | Front wiper motor |
| 24 | - | Not used |
| 25 | 20A | Power point |
| 26 | 20A | Power locks, Liftgate (wagon)/Trunk (sedan) release |
| 27 | 10A | Anti-lock Brake System (ABS), Speed control, Traction control, Brake-shift interlock, A/C function switch (manual A/C only), Temperature blend door (manual A/C only), Defrost coil |
| 28 | 15A | Turn signals, Back-up lamps |
| 29 | 20A | Cigar lighter |
| 30 | 10A | Courtesy lighting, Battery saver, Power mirrors, Decklid lamp, Power antenna (wagon only), Pulse stretching module (wagon only), Glove box lamp |
| 31 | 10A | Blower motor relay coil, Puddle lamp relay coil, Electronic Automatic Temperature Control (EATC) logic |
| 32 | 10A | Cluster, Flex fuel module, ICP logic, Passive anti-theft module (GEM power) |
| 33 | 15A | Hazard flasher, Cluster power, ICP power, EATC |
| 34 | 5A | GEM logic |
| 35 | 10A | Backlighting, Ashtray light |
| 36 | 2A | Powertrain Control Module (PCM) relay, Fuel pump relay, A/C clutch |
| 37 | 25A | Autolamp, Daytime Running Lamps (DRL), Flash-to-pass, Headlamp switch |
| 38 | 15A | Horn, Diagnostic connector (OBD II) |
| 39 | - | Not used |
| 40 | - | Not used |
| 41 | - | Not used |
| 42 | - | Not used |
| CB - Circuit Breaker | ||
Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 60A** | Fuse junction panel |
| 2 | 30A** | Powertrain Control Module (PCM) |
| 3 | 60A** | Fuse junction panel |
| 4 | 10A Circuit breaker | Low speed cooling fan |
| 5 | 40A** | Cooling fan (main) |
| 6 | - | Not used |
| 7 | 40A** | Starter relay, Ignition switch |
| 8 | - | Not used |
| 9 | 20A** | Cooling fan (passenger side) |
| 10 | 20A** | Cooling fan (driver side) |
| 11 | 50A** | Rear defrost (sedan only) |
| 12 | - | Not used |
| 13 | 40A** | Anti-lock Brake System (ABS) module pump feed |
| 14 | - | Not used |
| 15 | 20A* | ABS module valve solenoid |
| 16 | 20A* | Fuel pump relay |
| 17 | 20A* | CD |
| 18 | 10A* (Vulcan engine only) | A/C clutch relay, PCM keep alive power |
| - (Duratec engine only) | Not used | |
| 19 | - | Not used |
| 20 | - | Not used |
| 21 | - | Not used |
| 22 | 5A* (Vulcan engine only) | Heated PCV valve |
| 10A* (Duratec engine only) | A/C clutch relay, PCM keep alive power | |
| 23 | - | Starter motor relay |
| 24 | - | Fan relay |
| 25 | - | Wiper speed relay |
| 26 | 10A* | Alternator |
| 27 | 5A* | Rear control unit, Antenna |
| 28 | 15A* | HEGO sensor, Transmission shift solenoid, Canister vent, A/C clutch relay |
| 29 | - | Wiper park relay |
| 30 | - | Fuel pump relay |
| 31 | - | PCM power relay |
| 32 | - | Fan relay |
| 33 | - | A/C clutch relay |
| * Mini Fuses **Maxi Fuses CB - Circuit breaker | ||
2006
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | - | Accessory delay relay |
| 2 | - | Driver one touch down relay |
| 3 | - | Blower motor relay |
| 4 | - | Flasher relay |
| 5 | - | Not used |
| 6 | - | Not used |
| 7 | 20A | Rear defrost relay coil feed |
| 8 | 40A | Blower motor |
| 9 | - | Rear defrost relay |
| 10 | 30A CB | Power seats, Delayed accessory |
| 11 | 10A | Right headlamp |
| 12 | 15A | Highbeam headlamps |
| 13 | - | Not used |
| 14 | - | Not used |
| 15 | 10A | Left headlamp |
| 16 | 10A | Not used (spare) |
| 17 | 15A | Stop lamp, Speed control deactivation switch |
| 18 | 15A | Parklamps, PWM (backlighting), Autolamps |
| 19 | 10A | Heated mirrors, Rear defrost switch indicator |
| 20 | 10A | Restraints (air bag module/OCS module) |
| 21 | 15A | Transmission range sensor (transmission position switch) |
| 22 | 15A | Front washer pump, Cluster (RUN/ACC), Integrated Control Panei (ICP) logic, Electrochromatic mirror |
| 23 | 30A | Front wiper motor |
| 24 | - | Not used |
| 25 | 20A | Power point |
| 26 | 20A | Power locks, Trunk release |
| 27 | 10A | Anti-lock Brake System (ABS), Speed control, Traction control, Brake-shift interlock, A/C function switch (manual A/C only), Temperature blend door (manual A/C only), Defrost coil |
| 28 | 15A | Turn signals, Back-up lamps |
| 29 | 20A | Cigar lighter |
| 30 | 10A | Courtesy lighting, Battery saver, Power mirrors, Decklid lamp, Glove box lamp |
| 31 | 10A | Blower motor relay coil, Electronic Automatic Temperature Control (EATC) logic |
| 32 | 10A | Cluster, Flex fuel module, ICP logic, Passive anti-theft module (GEM power), Compass |
| 33 | 15A | Hazard flasher, Cluster power, ICP power, EATC |
| 34 | 5A | GEM logic |
| 35 | 10A | Backlighting, Ashtray light |
| 36 | 2A | Powertrain Control Module (PCM) relay, Fuel pump relay, A/C clutch |
| 37 | 25A | Autolamp, Daytime Running Lamps (DRL), Flash-to-pass, Headlamp switch |
| 38 | 15A | Horn, Diagnostic connector (OBD II) |
| 39 | - | Not used |
| 40 | - | Not used |
| 41 | - | Not used |
| 42 | - | Not used |
| CB - Circuit Breaker | ||
Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 60A** | Fuse junction panel |
| 2 | 30A** | Powertrain Control Module (PCM) |
| 3 | 60A** | Fuse junction panel |
| 4 | 10A CB | Low speed cooling fan |
| 5 | 40A** | Cooling fan (main) |
| 6 | - | Not used |
| 7 | 40A** | Starter relay, Ignition switch |
| 8 | - | Not used |
| 9 | 20A** | Cooling fan (passenger side) |
| 10 | 20A** | Cooling fan (driver side) |
| 11 | 50A** | Rear defrost |
| 12 | - | Not used |
| 13 | 40A** | Anti-lock Brake System (ABS) module pump feed |
| 14 | - | Not used |
| 15 | 20A* | ABS module valve solenoid |
| 16 | 20A* | Fuel pump relay |
| 17 | 20A* | CD |
| 18 | 10A* | A/C clutch relay, PCM keep alive power |
| 19 | - | Not used |
| 20 | - | Not used |
| 21 | - | Not used |
| 22 | 5A* | Heated PCV valve |
| 23 | - | Starter motor relay |
| 24 | - | Fan relay |
| 25 | - | Wiper speed relay |
| 26 | 10A* | Alternator |
| 27 | 5A* | Rear control unit |
| 28 | 15A* | HEGO sensor, Transmission shift solenoid, A/C clutch relay, Canister vent |
| 29 | - | Wiper park relay |
| 30 | - | Fuel pump relay |
| 31 | - | PCM power relay |
| 32 | - | Fan relay |
| 33 | - | A/C clutch relay |
| *Mini Fuses **Maxi Fuses CB - Circuit breaker | ||
2007
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | - | Accessory delay relay |
| 2 | - | Driver one touch down relay |
| 3 | - | Blower motor relay |
| 4 | - | Flasher relay |
| 5 | - | Not used |
| 6 | - | Not used |
| 7 | 20A | Rear defrost relay coil feed |
| 8 | 40A | Blower motor |
| 9 | - | Rear defrost relay |
| 10 | 30A CB | Power seats, Delayed accessory |
| 11 | 10A | Left headlamp |
| 12 | 15A | Highbeam headlamps |
| 13 | - | Not used |
| 14 | - | Not used |
| 15 | 10A | Right headlamp |
| 16 | 10A | Not used (spare) |
| 17 | 15A | Stop lamp, Speed control deactivation switch |
| 18 | 15A | Parklamps, PWM (backlighting), Autolamps |
| 19 | 10A | Heated mirrors, Rear defrost switch indicator |
| 20 | 10A | Restraints (air bag module/OCS module) |
| 21 | 15A | Transmission range sensor (transmission position switch) |
| 22 | 15A | Front washer pump, Cluster (RUN/ACC), Integrated Control Panel (ICP) logic, Electrochromatic mirror |
| 23 | 30A | Front wiper motor |
| 24 | - | Not used |
| 25 | 20A | Power point |
| 26 | 20A | Power locks, Trunk release |
| 27 | 10A | Anti-lock Brake System (ABS), Speed control, Traction control, Brake-shift interlock, A/C function switch (manual A/C only), Temperature blend door (manual A/C only), Defrost coil |
| 28 | 15A | Turn signals, Back-up lamps |
| 29 | 20A | Cigar lighter |
| 30 | 10A | Courtesy lighting, Battery saver, Power mirrors, Decklid lamp, Glove box lamp |
| 31 | 10A | Blower motor relay coil, Electronic Automatic Temperature Control (EATC) logic |
| 32 | 10A | Cluster, Flex fuel module, ICP logic, Passive anti-theft module (GEM power), Compass |
| 33 | 15A | Hazard flasher, Cluster power, ICP power, EATC |
| 34 | 5A | GEM logic |
| 35 | 10A | Backlighting, Ashtray light |
| 36 | 2A | Powertrain Control Module (PCM) relay, Fuel pump relay, A/C clutch |
| 37 | 25A | Autolamp, Daytime Running Lamps (DRL), Flash-to-pass, Headlamp switch |
| 38 | 15A | Horn, Diagnostic connector (OBD II) |
| 39 | - | Not used |
| 40 | - | Not used |
| 41 | - | Not used |
| 42 | - | Not used |
| CB - Circuit Breaker | ||
Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 60A** | Fuse junction panel |
| 2 | 30A** | Powertrain Control Module (PCM) |
| 3 | 60A** | Fuse junction panel |
| 4 | 10A CB | Low speed cooling fan |
| 5 | 40A** | Cooling fan (main) |
| 6 | - | Not used |
| 7 | 40A** | Starter relay, Ignition switch |
| 8 | - | Not used |
| 9 | 20A** | Cooling fan (passenger side) |
| 10 | 20A** | Cooling fan (driver side) |
| 11 | 50A** | Rear defrost |
| 12 | - | Not used |
| 13 | 40A** | Anti-lock Brake System (ABS) module pump feed |
| 14 | - | Not used |
| 15 | 20A* | ABS module valve solenoid |
| 16 | 20A* | Fuel pump relay |
| 17 | 20A* | CD |
| 18 | 10A* | A/C clutch relay, PCM keep alive power |
| 19 | - | Not used |
| 20 | - | Not used |
| 21 | - | Not used |
| 22 | 5A* | Heated PCV valve |
| 23 | - | Starter motor relay |
| 24 | - | Fan relay |
| 25 | - | Wiper speed relay |
| 26 | 10A* | Alternator |
| 27 | 5A* | Rear control unit |
| 28 | 15A* | HEGO sensor, Transmission shift solenoid, A/C clutch relay, Canister vent |
| 29 | - | Wiper park relay |
| 30 | - | Fuel pump relay |
| 31 | - | PCM power relay |
| 32 | - | Fan relay |
| 33 | - | A/C clutch relay |
| *Mini Fuses **Maxi Fuses CB - Circuit breaker | ||