Page Contents:
In this article, you will find information about the fuses of the Ford Ranger (models 2001, 2002, and 2003), including diagrams of the fuse boxes, a list of fuses, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in Ford Ranger
If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
Caution!
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Always disconnect the battery before servicing high current fuses.
- Always replace the cover to the Power Distribution Box before reconnecting the battery or refilling fluid reservoirs.
Location of Fuse Boxes
Passenger Compartment Fuse Panel:
The fuse panel is located on the left hand side of the instrument panel facing the driver’s side door. Pull the panel cover outward to access the fuses.
Power Distribution Box:
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
Fuse Box Diagrams
2001
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | 5A | Power Mirror Switch |
| 2 | 10A | Daytime Running Lights (DRL), Back-up Lamps, Transmission, Passenger Air Bag Deactivation Switch, Blower Motor Relay |
| 3 | 7.5A | Right Stop/Turn Trailer Tow Connector |
| 4 | - | Not Used |
| 5 | 15A | 4x4 Control Module |
| 6 | - | Not Used |
| 7 | 7.5A | Left Stop/Turn Trailer Tow Connector |
| 8 | - | Not Used |
| 9 | 7.5A | Brake Pedal Position Switch |
| 10 | 7.5A | Speed Control Servo/Amplifier Assembly, Generic Electronic Module (GEM), Shift Lock Actuator, Turn Signals |
| 11 | 7.5A | Instrument Cluster, 4x4, Main Light Switch, Truck Central Security Module (TCSM) |
| 12 | - | Not Used |
| 13 | 20A | Brake Pedal Position Switch |
| 14 | 10A or Not Used | 10A: If equipped with Anti-Lock Brake System (ABS) Control Module |
| 15 | - | Not Used |
| 16 | 30A | Windshield Wiper Motor, Wiper Hi-Lo Relay, Wiper Run/Park Relay |
| 17 | 20A | Cigar Lighter, Data Link Connector (DLC) |
| 18 | - | Not Used |
| 19 | 25A | PCM Power Diode, Ignition, PATS |
| 20 | 7.5A | Generic Electronic Module (GEM), Radio |
| 21 | 15A | Flasher (Hazard) |
| 22 | 20A | Auxiliary Power Socket |
| 23 | - | Not Used |
| 24 | 7.5A | Clutch Pedal Position (CPP) switch, Starter Intermpt Relay |
| 25 | - | Not Used |
| 26 | 10A | Battery Saver Relay, Auxiliary Relay Box, Restraint Central Module (RCM), Generic Electroic Module (GEM), Instrument Cluster |
| 27 | - | Not Used |
| 28 | 7.5A | Generic Electronic Module (GEM), Radio |
| 29 | 20A | Radio |
| 30 | - | Not Used |
| 31 | - | Not Used |
| 32 | - | Not Used |
| 33 | 15A | Headlamps, Daytime Running Lamps (DRL) Module, Instrument Cluster |
| 34 | - | Not Used |
| 35 | 15A or Not Used | 15A: Horn Relay (if Not Equipped with Truck Central Security Module) |
| 36 | - | Not Used |
Power Distribution Box
2.3L engine (if equipped)
| № | A | Description |
|---|---|---|
| 1 | 50A** | I/P Fuse Panel |
| 2 | - | Not Used |
| 3 | - | Not Used |
| 4 | - | Not Used |
| 5 | - | Not Used |
| 6 | 50A** | ABS Pump Motor |
| 7 | 30A* | Powertrain Control Module (PCM) |
| 8 | 20A* | Power Door Locks and Remote Entry |
| 9 | - | Not Used |
| 10 | - | Not Used |
| 11 | 50A** | Starter Relay, Ignition Switch |
| 12 | 20A* | Power Windows |
| 13 | - | Not Used |
| 14 | - | Not Used |
| 15 | - | Not Used |
| 16 | 40A** | Blower Motor |
| 17 | 20A** | Auxiliary Cooling Fan |
| 18 | - | Not Used |
| 19 | - | Not Used |
| 20 | - | Not Used |
| 21 | 10A* | PCM Memory |
| 22 | - | Not Used |
| 23 | 20A* | Fuel Pump Motor |
| 24 | 30A* | Headlamps |
| 25 | 10A* | A/C Clutch Solenoid |
| 26 | - | Not Used |
| 27 | - | Not Used |
| 28 | 30A* | 4WABS Module |
| 29 | - | Not Used |
| 30 | 15A* | Trailer Tow |
| 31 | 20A* | Foglamps, DRL |
| 32 | - | Not Used |
| 33 | 15A* | Park Lamp |
| 34 | - | Not Used |
| 35 | - | Not Used |
| 36 | - | Not Used |
| 37 | - | Not Used |
| 38 | 10A* | Left Headlamp Low Beam |
| 39 | - | Not Used |
| 40 | - | Not Used |
| 41 | 20A* | Heated Oxygen Sensors |
| 42 | 10A* | Right Headlamp Low Beam |
| 43 | - | (Resistor) |
| 44 | Not Used | |
| 45A | - | Wiper HI/LO |
| 45B | - | Wiper Park/Run |
| 46A | - | Fuel Pump |
| 46B | - | Trailer Tow |
| 47 | - | Starter |
| 48 | - | Auxiliary Cooling Fan |
| 49 | - | Not Used |
| 50 | - | Not Used |
| 51 | - | Not Used |
| 52 | - | Not Used |
| 53 | - | Powertrain Control Module (PCM) Diode |
| 54 | - | Powertrain Control Module (PCM) |
| 55 | - | Blower |
| 56A | - | A/C Clutch Solenoid |
| 56B | - | Front Washer Pump |
| * Mini Fuses ** Maxi Fuses | ||
3.0L and 4.0L engines (if equipped)
| № | A | Description |
|---|---|---|
| 1 | 50A** | I/P Fuse Panel |
| 2 | - | Not Used |
| 3 | - | Not Used |
| 4 | - | Not Used |
| 5 | - | Not Used |
| 6 | 50A** | ABS Pump Motor |
| 7 | 30A* | Powertrain Control Module (PCM) |
| 8 | 20A* | Power Door Locks and Remote Entry |
| 9 | - | Not Used |
| 10 | - | Not Used |
| 11 | 50A** | Starter Relay, Ignition Switch |
| 12 | 20A* | Power Windows |
| 13 | 20A* | 4x4 Motor |
| 14 | - | Not Used |
| 15 | - | Not Used |
| 16 | 40A** | Blower Motor |
| 17 | - | Not Used |
| 18 | - | Not Used |
| 19 | - | Not Used |
| 20 | - | Not Used |
| 21 | 10A* | PCM Memory |
| 22 | - | Not Used |
| 23 | 20A* | Fuel Pump Motor |
| 24 | 30A* | Headlamps |
| 25 | 10A* | A/C Clutch Solenoid |
| 26 | - | Not Used |
| 27 | - | Not Used |
| 28 | 30A* | 4WABS Module |
| 29 | - | Not Used |
| 30 | 15A* | Trailer Tow |
| 31 | 20A* | Foglamps, Daytime Running Lamps (DRL) |
| 32 | - | Not Used |
| 33 | 15A* | Park Lamp |
| 34 | - | Not Used |
| 35 | - | Not Used |
| 36 | - | Not Used |
| 37 | - | Not Used |
| 38 | 10A* | Left Headlamp Low Beam |
| 39 | - | Not Used |
| 40 | - | Not Used |
| 41 | 20A* | Heated Oxygen Sensors |
| 42 | 10A* | Right Headlamp Low Beam |
| 43 | Not Used | |
| 44 | - | Not Used |
| 45A | - | Wiper High/Low |
| 45B | - | Wiper Park/Run |
| 46A | - | Not Used |
| 46B | - | Front Washer Pump |
| 47A | - | Not Used |
| 47B | - | Not Used |
| 48A | - | Fog Lamps |
| 48B | - | Fog Lamp Relay |
| 49 | - | Full Starter |
| 50A | - | Not Used |
| 50B | - | Fuel Pump |
| 51 | - | Not Used |
| 52 | - | Not Used |
| 53 | - | Powertrain Control Module (PCM) Diode |
| 54 | - | Powertrain Control Module (PCM) |
| 55 | - | Blower |
| 56A | - | A/C Clutch Solenoid |
| 56B | - | Trailer Tow |
| * Mini Fuses ** Maxi Fuses | ||
2002
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | 5A | Power mirror switch |
| 2 | 10A | Daytime Running Lights (DRL), Back-up lamps, Transmission, Passenger air bag deactivation switch, Blower motor relay |
| 3 | 7.5A | Right stop/turn trailer tow connector |
| 4 | - | Not used |
| 5 | 15A | 4x4 control module |
| 6 | 2A | Brake pressure switch |
| 7 | 7.5A | Left stop/turn trailer tow connector |
| 8 | - | Not used |
| 9 | 7.5A | Brake pedal position switch |
| 10 | 7.5A | Speed control servo/amplifier assembly, Generic Electronic Module (GEM), Shift lock actuator, Turn signals |
| 11 | 7.5A | Instrument cluster, 4x4, Main light switch, Truck Central Security Module (TCSM) |
| 12 | - | Not used |
| 13 | 20A | Brake pedal position switch |
| 14 | 10A or Not Used | 10A: ABS control module |
| 15 | - | Not used |
| 16 | 30A | Windshield wiper motor, Wiper HI/LO relay, Wiper run/park relay |
| 17 | 20A | Cigar lighter, Data Link Connector (DLC) |
| 18 | - | Not used |
| 19 | 25A | Powertrain Control Module (PCM) power diode, Ignition, PATS |
| 20 | 7.5A | GEM, Radio |
| 21 | 15A | Hazard flasher |
| 22 | 20A | Auxiliary power socket |
| 23 | - | Not used |
| 24 | 7.5A | Clutch Pedal Position (CPP) switch, Starter interrupt relay |
| 25 | - | Not used |
| 26 | 10A | Battery saver relay, Auxiliary relay box, Restraint Central Module (RCM), Generic Electronic Module (GEM), Instrument cluster |
| 27 | - | Not used |
| 28 | 7.5A | GEM, Radio |
| 29 | 20A | Radio |
| 30 | - | Not used |
| 31 | - | Not used |
| 32 | - | Not used |
| 33 | 15A | Headlamps, DRL module, Instrument cluster |
| 34 | - | Not used |
| 35 | 15A or Not Used | 15A: Horn relay (if not equipped with a truck CSM) |
| 36 | - | Not used |
Power Distribution Box
2.3L engine (if equipped)
| № | A | Description |
|---|---|---|
| 1 | 50A** | I/P fuse panel |
| 2 | - | Not used |
| 3 | - | Not used |
| 4 | - | Not used |
| 5 | - | Not used |
| 6 | 50A** | Anti-lock Brake System (ABS) pump motor |
| 7 | 30A* | Powertrain Control Module (PCM) |
| 8 | 20A* | Power door locks, Remote entry |
| 9 | - | Not used |
| 10 | - | Not used |
| 11 | 50A** | Starter relay, Ignition switch |
| 12 | 20A* | Power Windows |
| 13 | - | Not used |
| 14 | - | Not used |
| 15 | - | Not used |
| 16 | 40A** | Blower motor |
| 17 | 20A** | Auxiliary cooling fan |
| 18 | - | Not used |
| 19 | - | Not used |
| 20 | - | Not used |
| 21 | 10A* | PCM memory |
| 22 | - | Not used |
| 23 | 20A* | Fuel pump motor |
| 24 | 30A* | Headlamps |
| 25 | 10A* | A/C clutch solenoid |
| 26 | - | Not used |
| 27 | - | Not used |
| 28 | 30A* | ABS module |
| 29 | - | Not used |
| 30 | 15A* | Trailer tow |
| 31 | 20A* | Foglamps, Daytime Running Lamps (DRL) |
| 32 | - | Not used |
| 33 | 15A* | Park Lamp |
| 34 | - | Not used |
| 35 | - | Not used |
| 36 | - | Not used |
| 37 | - | Not used |
| 38 | 10A* | Left headlamp low beam |
| 39 | - | Not used |
| 40 | - | Not used |
| 41 | 20A* | Heated oxygen sensors |
| 42 | 10A* | Right headlamp low beam |
| 43 | (Resistor) | |
| 44 | - | Not used |
| 45A | - | Wiper HI/LO |
| 45B | - | Wiper park/run |
| 46A | - | Fuel pump |
| 46B | - | Trailer tow |
| 47 | - | Starter |
| 48 | - | Auxiliary cooling fan |
| 49 | - | Not used |
| 50 | - | Not used |
| 51 | - | Not used |
| 52 | - | Not used |
| 53 | - | PCM Diode |
| 54 | - | PCM |
| 55 | - | Blower |
| 56A | - | A/C clutch solenoid |
| 56B | - | Front washer pump |
| * Mini Fuses ** Maxi Fuses | ||
3.0L and 4.0L engines (if equipped)
| № | A | Description |
|---|---|---|
| 1 | 50A** | I/P fuse panel |
| 2 | 50A** | Amplifier |
| 3 | - | Not used |
| 4 | - | Not used |
| 5 | - | Not used |
| 6 | 50A** | Anti-lock Brake System (ABS) pump motor |
| 7 | 30A* | Powertrain Control Module (PCM) |
| 8 | 20A* | Power door locks, Remote entry |
| 9 | - | Not used |
| 10 | - | Not used |
| 11 | 50A** | Starter relay, Ignition switch |
| 12 | 20A* | Power Windows |
| 13 | 20A* | 4x4 Motor |
| 14 | - | Not used |
| 15 | - | Not used |
| 16 | 40A** | Blower motor |
| 17 | - | Not used |
| 18 | - | Not used |
| 19 | - | Not used |
| 20 | - | Not used |
| 21 | 10A* | PCM memory |
| 22 | - | Not used |
| 23 | 20A* | Fuel pump motor |
| 24 | 30A* | Headlamps |
| 25 | 10A* | A/C clutch solenoid |
| 26 | - | Not used |
| 27 | - | Not used |
| 28 | 30A* | ABS Module |
| 29 | - | Not used |
| 30 | 15A* | Trailer tow |
| 31 | 20A* | Foglamps, Daytime Running Lamps (DRL) |
| 32 | - | Not used |
| 33 | 15A* | Park lamp |
| 34 | - | Not used |
| 35 | - | Not used |
| 36 | - | Not used |
| 37 | - | Not used |
| 38 | 10A* | Left headlamp low beam |
| 39 | - | Not used |
| 40 | - | Not used |
| 41 | 20A* | Heated oxygen sensors |
| 42 | 10A* | Right headlamp low beam |
| 43 | Not used | |
| 44 | - | Not used |
| 45A | - | Wiper HI/LO |
| 45B | - | Wiper park/run |
| 46A | - | Fuel pump |
| 46B | - | Trailer tow |
| 47A | - | A/C clutch solenoid |
| 47B | - | Front washer pump |
| 48A | - | Fog lamps |
| 48B | - | Fog lamp relay |
| 51 | - | Not used |
| 52 | - | Not used |
| 53 | - | PCM Diode |
| 54 | - | PCM |
| 55 | - | Blower |
| 56 | - | Starter |
| * Mini Fuses ** Maxi Fuses | ||
2003
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | 5A | Power mirror switch |
| 2 | 10A | Daytime Running Lights (DRL), Back-up lamps, Transmission, Passenger air bag deactivation switch, Blower motor relay |
| 3 | 7.5A | Left stop/turn trailer tow connector |
| 4 | - | Not used |
| 5 | 15A | 4x4 control module |
| 6 | 2A | Brake pressure switch |
| 7 | 7.5A | Right stop/turn trailer tow connector |
| 8 | - | Not used |
| 9 | 7.5A | Brake pedal position switch |
| 10 | 7.5A | Speed control servo/amplifier assembly, Generic Electronic Module (GEM), Shift lock actuator, Turn signals, 4x4 |
| 11 | 7.5A | Instrument cluster, 4x4, Main light switch, Truck Central Security Module (TCSM), GEM |
| 12 | - | Not used |
| 13 | 20A | Brake pedal position switch |
| 14 | 10A | ABS control module |
| 15 | - | Not used |
| 16 | 30A | Windshield wiper motor, Wiper HI/LO relay, Wiper run/park relay |
| 17 | 20A | Cigar lighter, Data Link Connector (DLC) |
| 18 | - | Not used |
| 19 | 25A | Powertrain Control Module (PCM) power diode, Ignition, PATS |
| 20 | 7.5A | GEM, Radio |
| 21 | 15A | Hazard flasher |
| 22 | 20A | Auxiliary power socket |
| 23 | - | Not used |
| 24 | 7.5A | Clutch Pedal Position (CPP) switch, Starter interrupt relay |
| 25 | - | Not used |
| 26 | 10A | Battery saver relay, Auxiliary relay box, Restraint Central Module (RCM), Generic Electronic Module (GEM), Instrument cluster |
| 27 | - | Not used |
| 28 | 7.5A | GEM, Radio |
| 29 | 20A | Radio |
| 30 | - | Not used |
| 31 | - | Not used |
| 32 | - | Not used |
| 33 | 15A | Headlamps, DRL module, Instrument cluster |
| 34 | - | Not used |
| 35 | 15A or Not Used | 15A: Horn relay (if not equipped with a truck CSM) |
| 36 | - | Not used |
Power Distribution Box
2.3L engine (if equipped)
| № | A | Description |
|---|---|---|
| 1 | 50A** | I/P fuse panel |
| 2 | - | Not used |
| 3 | - | Not used |
| 4 | - | Not used |
| 5 | - | Not used |
| 6 | 50A** | Anti-lock Brake System (ABS) pump motor |
| 7 | 30A* | Powertrain Control Module (PCM) |
| 8 | 20A* | Power door locks, Remote entry |
| 9 | - | Not used |
| 10 | - | Not used |
| 11 | 50A** | Starter relay, Ignition switch |
| 12 | 20A* | Power Windows |
| 13 | - | Not used |
| 14 | - | Not used |
| 15 | - | Not used |
| 16 | 40A** | Blower motor |
| 17 | 20A** | Auxiliary cooling fan |
| 18 | - | Not used |
| 19 | - | Not used |
| 20 | - | Not used |
| 21 | 10A* | PCM memory |
| 22 | - | Not used |
| 23 | 20A* | Fuel pump motor |
| 24 | 30A* | Headlamps |
| 25 | 10A* | A/C clutch solenoid |
| 26 | - | Not used |
| 27 | - | Not used |
| 28 | 30A* | ABS module |
| 29 | - | Not used |
| 30 | 15A* | Trailer tow |
| 31 | 20A* | Foglamps, Daytime Running Lamps (DRL) |
| 32 | - | Not used |
| 33 | 15A* | Park Lamp |
| 34 | - | Not used |
| 35 | - | Not used |
| 36 | - | Not used |
| 37 | - | Not used |
| 38 | 10A* | Left headlamp low beam |
| 39 | - | Not used |
| 40 | - | Not used |
| 41 | 20A* | Heated oxygen sensors |
| 42 | 10A* | Right headlamp low beam |
| 43 | - | (Resistor) |
| 44 | - | Not used |
| 45A | - | Wiper HI/LO |
| 45B | - | Wiper park/run |
| 46A | - | Fuel pump |
| 46B | - | Trailer tow |
| 47 | - | Starter |
| 48 | - | Auxiliary cooling fan |
| 49 | - | Not used |
| 50 | - | Not used |
| 51 | - | Not used |
| 52 | - | Not used |
| 53 | - | PCM Diode |
| 54 | - | PCM |
| 55 | - | Blower |
| 56A | - | A/C clutch solenoid |
| 56B | - | Front washer pump |
| * Mini Fuses ** Maxi Fuses | ||
3.0L and 4.0L engines (if equipped)
| № | A | Description |
|---|---|---|
| 1 | 50A** | I/P fuse panel |
| 2 | 50A** | Amplifier (Tremor audio system only) |
| 3 | - | Not used |
| 4 | - | Not used |
| 5 | - | Not used |
| 6 | 50A** | Anti-lock Brake System (ABS) pump motor |
| 7 | 30A* | Powertrain Control Module (PCM) |
| 8 | 20A* | Power door locks, Remote entry |
| 9 | - | Not used |
| 10 | - | Not used |
| 11 | 50A** | Starter relay, Ignition switch |
| 12 | 20A* | Power Windows |
| 13 | 20A* | 4x4 Motor |
| 14 | - | Not used |
| 15 | - | Not used |
| 16 | 40A** | Blower motor |
| 17 | - | Not used |
| 18 | - | Not used |
| 19 | - | Not used |
| 20 | - | Not used |
| 21 | 10A* | PCM memory |
| 22 | - | Not used |
| 23 | 20A* | Fuel pump motor |
| 24 | 30A* | Headlamps |
| 25 | 10A* | A/C clutch solenoid |
| 26 | - | Not used |
| 27 | - | Not used |
| 28 | 30A* | ABS Module |
| 29 | - | Not used |
| 30 | 15A* | Trailer tow |
| 31 | 20A* | Foglamps, Daytime Running Lamps (DRL) |
| 32 | - | Not used |
| 33 | 15A* | Park lamp |
| 34 | - | Not used |
| 35 | - | Not used |
| 36 | - | Not used |
| 37 | - | Not used |
| 38 | 10A* | Left headlamp low beam |
| 39 | - | Not used |
| 40 | - | Not used |
| 41 | 20A* | Heated oxygen sensors |
| 42 | 10A* | Right headlamp low beam |
| 43 | - | Not used |
| 44 | - | Not used |
| 45A | - | Wiper HI/LO |
| 45B | - | Wiper park/run |
| 46A | - | Fuel pump |
| 46B | - | Trailer tow |
| 47A | - | A/C clutch solenoid |
| 47B | - | Front washer pump |
| 48A | - | Fog lamps |
| 48B | - | Fog lamp relay |
| 51 | - | Not used |
| 52 | - | Not used |
| 53 | - | PCM Diode |
| 54 | - | PCM |
| 55 | - | Blower |
| 56 | - | Starter |
| * Mini Fuses ** Maxi Fuses | ||