Page Contents:
In this article, you will find information about the fuses of the Ford Excursion (models 2002, 2003, 2004, and 2005), including diagrams of the fuse boxes, a list of fuses and relays, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in Ford Excursion
If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
Caution!
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Always disconnect the battery before servicing high current fuses.
- Always replace the cover to the Power Distribution Box before reconnecting the battery or refilling fluid reservoirs.
Location of Fuse Boxes
Passenger Compartment Fuse Panel:
The fuse panel is located below and to the left of the steering wheel by the brake pedal. Remove the panel cover to access the fuses. To remove the fuse panel cover, turn the panel fasteners counterclockwise.
Fuse Box Diagrams
2002
Passenger Compartment Fuse Panel / Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 15A* | Adjustable pedais |
| 2 | 20A* | Power point - floor console |
| 3 | 20A* | Power point - 3rd row |
| 4 | 20A* | Power point - instmment panel |
| 5 | 20A* | Power point - right rear quarter |
| 6 | 20A* | Trailer tow turn/stop relay |
| 7 | 30A* | High beam headlamps / Flash to pass |
| 8 | - | Not used |
| 9 | 20A* | Heated mirrors |
| 10 | 10A* | A/C clutch |
| 11 | 20A* | Radio (main) |
| 12 | 20A* | Cigar lighter / OBD II |
| 13 | 5A* | Power mirrors/switches |
| 14 | 15A* | Daytime running lamps |
| 15 | 10A* | Driver’s seat module memory |
| 16 | 15A* | Rear seat controller |
| 17 | 15A* | Exterior lamps |
| 18 | 20A* | Turn lamps/Brake on-off switch (high) |
| 19 | 10A* | Body security module/4x4 module |
| 20 | - | Not used |
| 21 | 25A* | Rear wiper motor |
| 22 | 20A* | Engine control |
| 23 | 20A* | Engine control |
| 24 | 15A* | Air suspension |
| 25 | 10A* | 4-Wheel Anti-Lock Brake System (4WABS) module |
| 26 | 10A* | Airbags |
| 27 | 15A* | Ignition switch Run feed |
| 28 | 10A* | EATC module module/Front blower relay coil |
| 29 | 10A* | Customer access |
| 30 | 15A* | Highbeam headlamps |
| 31 | 15A* | Clutch interlock switch |
| 32 | 5A* | Radio (start) |
| 33 | 15A* | Front wiper |
| 34 | 10A* | Brake on-off switch |
| 35 | 10A* | Instmment cluster |
| 36 | 10A* | PCM Keep-Alive |
| 37 | 15A* | Horn |
| 38 | 20A* | Trailer tow park lamps and backup lamps |
| 39 | - | Not used |
| 40 | 20A* | Fuel pump |
| 41 | 10A* | Instmment cluster |
| 42 | 15A* | Delayed accessory |
| 43 | 10A* | Fog lamps |
| 44 | 10A* | PATS module, transceiver |
| 45 | 10A* | Ignition switch Run/ Start feed |
| 46 | 10A* | Left-hand lowbeam |
| 47 | 10A* | Right-hand lowbeam |
| 48 | 10A* | Rear wiper motor |
| 101 | 30A** | Trailer tow electric brake |
| 102 | 30A** | Door locks/Body security module |
| 103 | 50A** | Ignition switch |
| 104 | 40A** | Heated backlite |
| 105 | 30A** | Injector driver module |
| 106 | 30A** | Front wiper main |
| 107 | 40A** | Front blower motor |
| 108 | 40A** | Auxiliary blower motor |
| 109 | 30A** | Heated seats |
| 110 | 50A** | Ignition switch |
| 111 | 30A** | 4WD/Shift on the fly |
| 112 | 30A** | Left-hand power seats |
| 113 | 30A** | Starter motor |
| 114 | 30A** | Right-hand power seats |
| 115 | 20A** | Trailer tow battery charge |
| 116 | 30A** | Ignition switch |
| 601 | 30A CB | Door window motors |
| 602 | 60A** | 4-Wheel Anti-Lock Brake System (4WABS) module |
| 210 | - | Not used |
| 211 | - | Not used |
| 212 | - | Not used |
| 301 | - | Front blower motor relay |
| 302 | - | Powertrain (EEC) relay |
| 303 | - | Injector driver module relay (Diesel only) |
| 304 | - | Heated backlite relay |
| 305 | - | Trailer tow battery charge relay |
| 306 | - | Delayed accessory relay |
| 307 | - | Starter relay |
| * Mini Fuses ** Maxi Fuses | ||
2003
Passenger Compartment Fuse Panel / Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 15A* | Adjustable pedais |
| 2 | 20A* | Power point - floor console |
| 3 | 20A* | Power point - 3rd row |
| 4 | 20A* | Power point - instmment panel |
| 5 | 20A* | Power point - right rear quarter |
| 6 | 20A* | Trailer tow turn/stop relay |
| 7 | 30A* | High beam headlamps / Flash to pass |
| 8 | - | Not used |
| 9 | 20A* | Heated mirrors |
| 10 | 10A* | A/C clutch |
| 11 | 20A* | Radio (main) |
| 12 | 20A* | Cigar lighter / OBD II |
| 13 | 5A* | Power mirrors/switches |
| 14 | 15A* | Daytime running lamps |
| 15 | 10A* | Driver's seat module memory |
| 16 | 15A* | Rear seat controller |
| 17 | 15A* | Exterior lamps |
| 18 | 20A* | Turn lamps/Brake on-off switch (high) |
| 19 | 10A* | Body security module/4x4 module |
| 20 | - | Not used |
| 21 | 25A* | Rear wiper motor |
| 22 | 20A* | Engine control |
| 23 | 20A* | Engine control |
| 24 | 15A* | Air suspension |
| 25 | 10A* | 4-Wheel Anti-Lock Brake System (4WABS) module |
| 26 | 10A* | Airbags |
| 27 | 15A* | Ignition switch Run feed |
| 28 | 10A* | EATC module module/Front blower relay coil |
| 29 | 10A* | Customer access |
| 30 | 15A* | Highbeam headlamps |
| 31 | 15A* | Clutch interlock switch |
| 32 | 5A* | Radio (start) |
| 33 | 15A* | Front wiper |
| 34 | 10A* | Brake on-off switch |
| 35 | 10A* | Instrument cluster |
| 36 | 10A* | PCM Keep-Alive |
| 37 | 15A* | Horn |
| 38 | 20A* | Trailer tow park lamps and backup lamps |
| 39 | - | Not used |
| 40 | 20A* | Fuel pump |
| 41 | 10A* | Instrument cluster |
| 42 | 15A* | Delayed accessory |
| 43 | 10A* | Fog lamps |
| 44 | 10A* | PATS module, transceiver |
| 45 | 10A* | Ignition switch Run/ Start feed |
| 46 | 10A* | Left-hand lowbeam |
| 47 | 10A* | Right-hand lowbeam |
| 48 | 10A* | Rear wiper motor |
| 101 | 30A** | Trailer tow electric brake |
| 102 | 30A** | Door locks/Body security module |
| 103 | 50A** | Ignition switch |
| 104 | 40A** | Heated backlite |
| 105 | 30A** | Injector driver module |
| 106 | 30A** | Front wiper main |
| 107 | 40A** | Front blower motor |
| 108 | 40A** | Auxiliary blower motor |
| 109 | 30A** | Heated seats |
| 110 | 50A** | Ignition switch |
| 111 | 30A** | 4WD/Shift on the fly |
| 112 | 30A** | Left-hand power seats |
| 113 | 30A** | Starter motor |
| 114 | 30A** | Right-hand power seats |
| 115 | 20A** | Trailer tow battery charge |
| 116 | 30A** | Ignition switch |
| 601 | 30A CB | Door window motors |
| 602 | 60A** | 4-Wheel Anti-Lock Brake System (4WABS) module |
| 210 | - | Not used |
| 211 | - | Not used |
| 212 | - | Not used |
| 301 | - | Front blower motor relay |
| 302 | - | Powertrain (EEC) relay |
| 303 | - | Injector driver module relay (Diesel only) |
| 304 | - | Heated backlite relay |
| 305 | - | Trailer tow battery charge relay |
| 306 | - | Delayed accessory relay |
| 307 | - | Starter relay |
| * Mini Fuses ** Maxi Fuses | ||
2004
Passenger Compartment Fuse Panel / Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 15A* | Adjustable pedais |
| 2 | 20A* | Power point - floor console |
| 3 | 20A* | Power point - 3rd row |
| 4 | 20A* | Power point - I/P |
| 5 | 20A* | Power point - right rear quarter |
| 6 | 20A* | Trailer tow turn/stop relay |
| 7 | 30A* | High beam headlamps / Flash to pass |
| 8 | 15A* | Backup lamps (Diesel engine only) |
| 9 | 20A* | Heated mirrors |
| 10 | 10A* | A/C clutch |
| 11 | 20A* | Radio (main) |
| 12 | 20A* | Cigar lighter/OBD II |
| 13 | 5A* | Power mirrors/switches |
| 14 | 15A* | Daytime mnning lamps (DRL) |
| 15 | 10A* | Driver’s seat module memory |
| 16 | 15A* | Rear seat controller |
| 17 | 15A* | Exterior lamps |
| 18 | 20A* | Turn lamps/Brake on-off switch (high) |
| 19 | 10A* | Body Security Module (BSM)/4x4 module |
| 20 | 10A* | Fuel Injection Control Module (FICM) relay (Diesel engine only) |
| 21 | 25A* | Rear smart wiper motor |
| 22 | 20A* | Engine control |
| 23 | 20A* | Engine control (gasoline engine only), Climate control (Diesel engine only) |
| 24 | 2A* | Brake pressure switch/Speed control |
| 25 | 10A* | 4-Wheel Anti-Lock Brake System (4WABS) module, Variable Fan Control (VFC) (Diesel engine only) |
| 26 | 10A* | Airbags |
| 27 | 15A* | Ignition switch Run feed |
| 28 | 10A* | EATC module/Front blower relay coil |
| 29 | 10A* | Customer access |
| 30 | 15A* | Highbeam headlamps |
| 31 | 15A* | Transmission range sensor (then to starter relay coil), 4x4 |
| 32 | 5A* | Radio (start) |
| 33 | 15A* | Front wiper |
| 34 | 10A* | Brake on-off switch |
| 35 | 10A* | Instrument cluster |
| 36 | 10A* | PCM Memory |
| 37 | 15A* | Horn |
| 38 | 20A* | Trailer tow park lamps |
| 39 | 15A* | Trailer tow back-up lamps |
| 40 | 20A* | Fuel pump |
| 41 | 10A* | Instrument cluster |
| 42 | 15A* | Delayed accessory |
| 43 | 10A* | Fog lamps |
| 44 | 10A* | PATS module, Transceiver |
| 45 | 10A* | Ignition switch Run/Start feed |
| 46 | 10A* | Left-hand lowbeam |
| 47 | 10A* | Right-hand lowbeam |
| 48 | 10A* | Rear smart wiper motor |
| 101 | 30A** | Trailer tow electric brake |
| 102 | 30A** | Door locks, BSM |
| 103 | 50A** | Ignition switch (gasoline engine only), FICM power (Diesel engine only) |
| 104 | 40A** | Heated backlight |
| 105 | 30A** | Fuel heater (Diesel engine only) |
| 106 | 30A** | Front wiper main |
| 107 | 40A** | Front blower motor |
| 108 | 40A** | Auxiliary blower motor |
| 109 | 30A** | Heated seats |
| 110 | 50A** | Ignition switch |
| 111 | 30A** | 4WD/Shift on the fly |
| 112 | 30A** | Left-hand power seats |
| 113 | 30A** | Starter motor |
| 114 | 30A** | Right-hand power seats |
| 115 | 20A** | Trailer tow battery charge |
| 116 | 30A** | Ignition switch |
| 601 | 30A CB | Window motors, Moonroof |
| 602 | 60A** | 4WABS module |
| 210 | - | Not used |
| 211 | - | Backup lamps relay (Diesel engine only) |
| 212 | - | Not used |
| 301 | - | Front blower motor relay |
| 302 | - | Powertrain Control Module (PCM) relay |
| 303 | - | Fuel heater relay (Diesel engine only) |
| 304 | - | Heated backlight relay |
| 305 | - | Trailer tow battery charge relay |
| 306 | - | Delayed accessory relay |
| 307 | - | Starter relay |
| Note: (Diesel engine only) The Fuel Injection Control Module (FICM) logic 10A mini-fuse is located in the underhood relay block. * Mini Fuses ** Maxi Fuses ***Circuit Breaker | ||
2005
Passenger Compartment Fuse Panel / Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 15A* | Adjustable pedais |
| 2 | 20A* | Power point - floor console |
| 3 | 20A* | Power point - 3rd row |
| 4 | 20A* | Power point - I/P |
| 5 | 20A* | Power point - right rear quarter |
| 6 | 20A* | Trailer tow turn/stop relay |
| 7 | 30A* | High beam headlamps / Flash to pass |
| 8 | 15A* | Backup lamps (Diesel engine only) |
| 9 | 20A* | Heated mirrors |
| 10 | 10A* | A/C clutch |
| 11 | 20A* | Radio (main) |
| 12 | 20A* | Cigar lighter/OBD II |
| 13 | 5A* | Power mirrors/switches |
| 14 | 15A* | Daytime running lamps (DRL) |
| 15 | 10A* | Driver’s seat module memory |
| 16 | 15A* | Rear seat controller |
| 17 | 15A* | Exterior lamps |
| 18 | 20A* | Turn lamps/Brake on-off switch (high) |
| 19 | 10A* | Body Security Module (BSM)/4x4 module |
| 20 | 10A* | Fuel Injection Control Module (FICM) relay (Diesel engine only) |
| 21 | 25A* | Rear smart wiper motor |
| 22 | 20A* | Engine control |
| 23 | 20A* | Engine control (gasoline engine only), Climate control (Diesel engine only) |
| 24 | 2A* | Brake pressure switch/Speed control |
| 25 | 10A* | 4-Wheel Anti-Lock Brake System (4WABS) module, Variable Fan Control (VFC) (Diesel engine only) |
| 26 | 10A* | Airbags |
| 27 | 15A* | Ignition switch Run feed |
| 28 | 10A* | EATC module/Front blower relay coil |
| 29 | 10A* | Customer access |
| 30 | 15A* | Highbeam headlamps |
| 31 | 15A* | Transmission range sensor (then to starter relay coil), 4x4 |
| 32 | 5A* | Radio (start) |
| 33 | 15A* | Front wiper |
| 34 | 10A* | Brake on-off switch |
| 35 | 10A* | Instrument cluster |
| 36 | 10A* | PCM Memory |
| 37 | 15A* | Horn |
| 38 | 20A* | Trailer tow park lamps |
| 39 | 15A* | Trailer tow back-up lamps |
| 40 | 20A* | Fuel pump |
| 41 | 10A* | Instrument cluster |
| 42 | 15A* | Delayed accessory |
| 43 | 10A* | Fog lamps |
| 44 | 10A* | PATS module, Transceiver |
| 45 | 10A* | Ignition switch Run/Start feed |
| 46 | 10A* | Left-hand lowbeam |
| 47 | 10A* | Right-hand lowbeam |
| 48 | 10A* | Rear smart wiper motor |
| 101 | 30A** | Trailer tow electric brake |
| 102 | 30A** | Door locks, BSM |
| 103 | 50A** | Ignition switch (gasoline engine only), FICM power (Diesel engine only) |
| 104 | 40A** | Heated backlight |
| 105 | 30A** | Fuel heater (Diesel engine only) |
| 106 | 30A** | Front wiper main |
| 107 | 40A** | Front blower motor |
| 108 | 40A** | Auxiliary blower motor |
| 109 | 30A** | Heated seats |
| 110 | 50A** | Ignition switch |
| 111 | 30A** | 4WD/Shift on the Hy |
| 112 | 30A** | Left-hand power seats |
| 113 | 30A** | Starter motor |
| 114 | 30A** | Right-hand power seats |
| 115 | 20A** | Trailer tow battery charge |
| 116 | 30A** | Ignition switch |
| 601 | 30A CB | Window motors, Moonroof |
| 602 | 60A** | 4WABS module |
| 210 | - | Not used |
| 211 | - | Backup lamps relay (Diesel engine only) |
| 212 | - | Not used |
| 301 | - | Front blower motor relay |
| 302 | - | Powertrain Control Module (PCM) relay |
| 303 | - | Fuel heater relay (Diesel engine only) |
| 304 | - | Heated backlight relay |
| 305 | - | Trailer tow battery charge relay |
| 306 | - | Delayed accessory relay |
| 307 | - | Starter relay |
| Note: (Diesel engine only) The Fuel Injection Control Module (FICM) logic 15A mini-fuse is located in the underhood relay block. * Mini Fuses ** Maxi Fuses ***Circuit Breaker | ||