Page Contents:
In this article, you will find information about the fuses of the Ford Excursion (models 2000 and 2001), including diagrams of the fuse boxes, a list of fuses and relays, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in Ford Excursion
If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components. To remove a fuse use the fuse puller tool provided on the fuse panel cover.
Caution!
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Always disconnect the battery before servicing high current fuses.
- Always replace the cover to the Power Distribution Box before reconnecting the battery or refilling fluid reservoirs.
Location of Fuse Boxes
Passenger Compartment Fuse Panel:
The fuse panel is located below and to the left of the steering wheel by the brake pedal. Remove the panel cover to access the fuses. To remove the fuse panel cover, turn the panel fasteners counterclockwise.
Power Distribution Box:
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
Fuse Box Diagrams
2000
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | 20A | Radio, Secondary Fusing for Audio Options |
| 2 | 5A | Instmment Cluster, Powertrain Control Module (PCM) Keep Alive Memory, PATS LED |
| 3 | 20A | Cigar Lighter, Data Link Connector |
| 4 | - | Not Used |
| 5 | 10A | Ignition Run Power Feed (Customer Access) |
| 6 | 15A | DRL, Brake Shift Interlock (BSI), ECM, Overhead Trip Computer (OTC), AUX A/C Components, Hazard Flasher, Speed Control, Vacuum Pump, Backup Lamps, Electronic Shift On The Fly Hublock Solenoid, Heated Seat |
| 7 | 5A | Power Window/Lock Switch Illumination |
| 8 | 5A | Headlamp Switch, LED/Radio |
| 9 | - | Not Used |
| 10 | - | Not Used |
| 11 | 30A | Wiper Run/Park Relay Coil, Wiper Hi/LO Relay Coil, Washer Pump Relay Coils, Front Wiper Motor, Rear Wiper Motor Relay Coils |
| 12 | - | Not Used |
| 13 | 20A | Stop Lamps, Center High-mount Stop Lamp/Hazard, Trailer Tow Stop Lamp, Speed Control |
| 14 | 15A | Dome Lamp, Cargo Lamp, Courtesy Lamps, Running Boards, Power Mirrors, Vanity Mirrors, Map Lamps, Underhood Lamps, Glove Box Lamp, Power Windows (Delayed Accessory) |
| 15 | 5A | Stop Lamp Switch (Logic), PATS, GEM |
| 16 | 15A | Hi-beam Headlamps, Instrument Cluster (Hi-beam Indicator) |
| 17 | 15A | Heated Mirrors, Rear Defroster "ON" indicator |
| 18 | 10A | Rear Integrated Control Panel (RICP), CD Changer |
| 19 | 10A | Instmment Cluster, GEM Module, Overdrive Cancel Switch, PATS/PATS Transiever, Idle Validation Switch (Diesel only) |
| 20 | 15A | Starter Motor Relay, GEM, Radio (w/Secondary) |
| 21 | 5A | Radio Start Feed |
| 22 | 10A | Air Bag Module, Blower Motor Relay Coil |
| 23 | - | Not Used |
| 24 | 10A | A/G Clutch, Blend Door Actuator, Trailer Tow Battery Charge Relay Coil |
| 25 | 5A | 4-Wheel Anti-Lock Brake System (4WABS) |
| 26 | - | Not Used |
| 27 | - | Not Used |
| 28 | - | Not Used |
| 29 | 5A | Instrument Cluster (Charge and Airbag Warning Lamps) |
| 30 | 30A | PCM Relay Coil, Ignition Coil (Gasoline only), Fuel Heater (Diesel only), Wastegate Solenoid (Diesel only), Injector Driver Module Relay Coil (Diesel only) |
| 31 | - | Not Used |
| Relay 1 | - | Interior Lamp Relay |
| Relay 2 | - | Battery Saver Relay |
| Relay 3 | - | Rear Defroster |
| Relay 4 | - | Power Window One Touch Down Relay |
| Relay 5 | - | Accessory Delay Relay |
Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 20A* | Rear Wiper |
| 2 | 10A* | Air Bag |
| 3 | 15A* | Quarter Flip Window Motor |
| 4 | 20A* | Trailer Tow Backup Lamps, Trailer Tow Park Lamps |
| 5 | 20A* | Instmment Panel Auxiliary Power Point |
| 6 | 10A* | Gasoline only - A/C (CASS) Diesel only-Alternator "A" Field |
| 7 | 20A* | Floor Console Auxiliary Power Point |
| 8 | 15A* | Park Lamps |
| 9 | 20A* | Left Rear Quarter Auxiliary Power Point |
| 10 | 30A* | Head Lamps |
| 11 | 20A* | Cargo Auxiliary Power Point |
| 12 | 15A* | DRL |
| 13 | 10A* | Washer |
| 14 | 15A* | Horn |
| 15 | - | Not Used |
| 16 | - | Not Used |
| 17 | - | Not Used |
| 18 | - | Not Used |
| 19 | 20A* (Gasoline only) - (Diesel only) | Gasoline only-E40D/HEGO Diesel only - Not Used |
| 20 | 7.5A* | Trailer Tow Stop/Turn LH |
| 21 | 10A* | Left Headlamp |
| 22 | 7.5A* | Trailer Tow Stop/Turn RH |
| 23 | 10A* | Right Headlamp |
| 24 | 20A* (Gasoline only) - (Diesel only) | Gasoline only-Engine Control Diesel only-Not Used |
| 101 | 50A** | Ignition Switch (B1 & B3) |
| 102 | 30A** | Power Door Locks |
| 103 | 40A** | Auxiliary Blower |
| 104 | 30A** | Electronic Shift On The Fly (Transfer Case Motor) |
| 105 | 50A** | Junction Box Battery Feed |
| 106 | - (Gasoline only) 30A** (Diesel only) | Gasoline only-Not Used Diesel only-Injector Driver Module |
| 107 | 30A** | Heated Seats |
| 108 | 30A** | Power Seats |
| 109 | 40A** | Front Blower Motor |
| 110 | 30A** | Trailer Tow Electronic Brake |
| 111 | - | Not Used |
| 112 | 20A** | Fuel Pump |
| 113 | 30A** (Gasoline only) 20A** (Diesel only) | PCM Power |
| 114 | - | Not Used |
| 115 | 30A** | Trailer Tow Battery Charge |
| 116 | 50A** | Ignition Switch (B4 & B5) |
| 117 | - | Not Used |
| 118 | 40A** | Rear Defroster |
| 201 | - | Park Lamp |
| 202 | - | Fuel Pump |
| 203 | - | Not Used |
| 204 | - | Quarter Flip Window Motor |
| 205 | - | Rear Wiper |
| 206 | - | Rear Washer |
| 207 | - | Wiper Run/Park |
| 208 | - | Wiper HI/LOW |
| 209 | - | Front Washer |
| 301 | - | Horn Relay |
| 302 | - | Gasoline only - A/C (CASS) Diesel only-Injector Driver Module Power Relay |
| 303 | - | Blower Motor |
| 304 | - | EEC Power |
| 401 | - | Not Used |
| 501 | - | Powertrain Control Module Diode |
| 502 | - | A/C Clutch Diode |
| 503 | - | Not Used |
| 601 | 30A CB | Power Windows |
| 602 | 60A** | Four Wheel Anti-Lock Brake Module |
| *Mini fuses **Maxi fuses | ||
2001
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | 20A | Radio, Secondary Fusing for Audio Options |
| 2 | 5A | Instmment Cluster, Powertrain Control Module (PCM) Keep Alive Memory, PATS LED |
| 3 | 20A | Cigar Lighter, Data Link Connector |
| 4 | - | Not Used |
| 5 | - | Not Used |
| 6 | - | Not Used |
| 7 | 5A | Power Window/Lock Switch Illumination |
| 8 | 5A | Headlamp Switch, LED/Radio |
| 9 | - | Not Used |
| 10 | - | Not Used |
| 11 | 30A | Wiper Run/Park Relay Coil, Wiper Hi/LO Relay Coil, Washer Pump Relay Coils, Front Wiper Motor, Rear Wiper Motor Relay Coils |
| 12 | - | Not Used |
| 13 | 20A | Stop Lamps, Center High-mount Stop Lamp/Hazard, Trailer Tow Stop Lamp, Speed Control |
| 14 | 15A | Dome Lamp, Cargo Lamp, Courtesy Lamps, Running Boards, Power Mirrors, Vanity Mirrors, Map Lamps, Underhood Lamps, Glove Box Lamp, Power Windows (Delayed Accessory) |
| 15 | 5A | Stop Lamp Switch (Logic), PATS, GEM |
| 16 | 15A | Hi-beam Headlamps, Instrument Cluster (Hi-beam Indicator) |
| 17 | - | Not Used |
| 18 | 10A | Rear Integrated Control Panel (RICP), CD Changer |
| 19 | 10A | Instrument Cluster, GEM Module, Overdrive Cancel Switch, PATS/PATS Transiever, Idle Validation Switch (Diesel only) |
| 20 | 15A | Starter Motor Relay, GEM |
| 21 | 5A | Radio Start Feed |
| 22 | 10A | Blower Motor Relay Coil |
| 23 | 10A | Air Bag Module |
| 24 | 10A | A/G Clutch, Blend Door Actuator, Trailer Tow Battery Charge Relay Coil, Rear Defroster |
| 25 | 5A | 4-Wheel Anti-Lock Brake System (4WABS) |
| 26 | - | Not Used |
| 27 | 10A | Ignition Run Power Feed (Customer Access) |
| 28 | 15A | DRL, Brake Shift Interlock (BSI), ECM, Overhead Trip Computer (OTC), AUX A/C Components, Hazard Flasher, Speed Control, Vacuum Pump, Backup Lamps, Electronic Shift On The Fly Hublock Solenoid, Heated Seat |
| 29 | 5A | Instrument Cluster (Charge and Airbag Warning Lamps) |
| 30 | 30A | PCM Relay Coil, Ignition Coil (Gasoline only), Fuel Heater (Diesel only), Wastegate Solenoid (Diesel only), Injector Driver Module Relay Coil (Diesel only) |
| 31 | 15A | Heated Mirrors, Rear Defroster "ON" indicator |
| Relay 1 | - | Interior Lamp Relay |
| Relay 2 | - | Battery Saver Relay |
| Relay 3 | - | Horn Relay |
| Relay 4 | - | Power Window One Touch Down Relay |
| Relay 5 | Accessory Delay Relay |
Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | 20A* | Rear Wiper |
| 2 | - | Not Used |
| 3 | 15A* | Quarter Flip Window Motor |
| 4 | 20A* | Trailer Tow Backup Lamps, Trailer Tow Park Lamps |
| 5 | 20A* | Instrument Panel Auxiliary Power Point |
| 6 | 10A* | Gasoline only - A/C (CASS) Diesel only-Alternator "A" Field |
| 7 | 20A* | Floor Console Auxiliary Power Point |
| 8 | 15A* | Park Lamps |
| 9 | 20A* | Left Rear Quarter Auxiliary Power Point |
| 10 | 30A* | Head Lamps |
| 11 | 20A* | Cargo Auxiliary Power Point |
| 12 | 15A* | DRL, Fog Lamp Relay |
| 13 | 10A* | Washer |
| 14 | 15A* | Horn |
| 15 | 5A* | Fog Lamps |
| 16 | - | Not Used |
| 17 | - | Not Used |
| 18 | - | Not Used |
| 19 | 20A* (Gasoline only) - (Diesel only) | Gasoline only-E40D/HEGO Diesel only-Not Used |
| 20 | 7.5A* | Trailer Tow Stop /Turn LH |
| 21 | 10A* | Left Headlamp |
| 22 | 7.5A* | Trailer Tow Stop /Turn RH |
| 23 | 10A* | Right Headlamp |
| 24 | 20A* (Gasoline only) - (Diesel only) | Gasoline only-Engine Control Diesel only-Not Used |
| 101 | 50A** | Ignition Switch (BI & B3) |
| 102 | 30A** | Power Door Locks |
| 103 | 40A** | Auxiliary Blower |
| 104 | 30A** | Electronic Shift On The Fly (Transfer Case Motor) |
| 105 | 50A** | Junction Box Battery Feed |
| 106 | - (Gasoline only) 30A** (Diesel only) | Gasoline only-Not Used Diesel only-Injector Driver Module |
| 107 | 30A** | Heated Seats |
| 108 | 30A** | Power Seats, Adjustable Pedais |
| 109 | 40A** | Front Blower Motor |
| 110 | 30A** | Trailer Tow Electronic Brake |
| 111 | - | Not Used |
| 112 | 20A** | Fuel Pump |
| 113 | 30A** (Gasoline only) 20A** (Diesel only) | PCM Power |
| 114 | - | Not Used |
| 115 | 30A** | Trailer Tow Battery Charge |
| 116 | 50A** | Ignition Switch (B4 & B5) |
| 117 | - | Not Used |
| 118 | 40A** | Rear Defroster |
| 201 | - | Park Lamp |
| 202 | - | Fuel Pump |
| 203 | - | Fog Lamps |
| 204 | - | Quarter Flip Window Motor |
| 205 | - | Rear Wiper |
| 206 | - | Rear Washer |
| 207 | - | Wiper Run/Park |
| 208 | - | Wiper HI/LOW |
| 209 | - | Front Washer |
| 301 | - | Rear Defroster |
| 302 | Gasoline only - A/C (CASS) Diesel only-Injector Driver Module Power Relay | |
| 303 | - | Blower Motor |
| 304 | - | EEC Power |
| 401 | - | Not Used |
| 501 | - | Powertrain Control Module Diode |
| 502 | - | A/C Clutch Diode |
| 503 | - | Not Used |
| 601 | 30A CB | Power Windows |
| 602 | 60A** | Four Wheel Anti-Lock Brake Module |
| *Mini fuses **Maxi fuses | ||