Page Contents:
In this article, you will find information about the fuses of the Chevrolet Aveo T300 (UK) (models 2012 and 2014), including diagrams of the fuse boxes, a list of fuses and relays, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in Chevy Aveo
A blown fuse can be recognised by its melted wire. Do not replace the fuse until the cause of the fault has been remedied. Before replacing a fuse, turn off the respective switch and the ignition. A fuse extractor may be located in the fuse box in the engine compartment.
Caution!
Data on the replacement fuse must match the data on the defective fuse.
Location of Fuse Boxes
Instrument Panel Fuse Box:
Interior fuse box is located in the glove box (right-hand drive vehicles).
Engine Compartment Fuse Box:
The fuse box is in the engine compartment. Disengage the cover, lift it upwards and remove.
In a box above the positive terminal of the vehicle battery are some main fuses. If necessary have them changed by a workshop.
Fuse Box Diagrams
2012
Instrument Panel Fuse Box
| № | Circuit |
|---|---|
| 1 | DLIS |
| 2 | DLC |
| 3 | Airbag |
| 4 | Tail gate |
| 5 | Spare fuse |
| 6-13 | Body control module |
| 14 | IPC |
| 15 | ONSTAR |
| 16 | Ultra parking assist |
| 17 | Driver information center |
| 18 | Audio |
| 19 | Trailer |
| 20 | VLBS |
| 21 | CHEVYSTAR |
| 22 | Heating, ventilation, air conditioning |
| 23 | HDLP ALC |
| 24 | Clutch |
| 25 | IPC-AOS |
| 26 | Airbag RUN/CRANK |
| 27 | Run relay |
| 28 | Tail gate relay |
| 29 | Trailer RUN/CRANK |
| 30 | Clock spring |
| 31 | Heating, ventilation, air conditioning |
| 32 | Spare fuse |
| 33 | Sunroof |
| 34 | Cigarette lighter |
| 35 | Spare fuse |
| 36 | Rear power window |
| 37 | Front power window |
| 38 | RAP/ACCY |
| 39 | DCDC CONV |
| 40 | Driver power window |
| 41 | PTC2 |
| 42 | PTC1 |
| 43 | Battery connector |
Engine Compartment Fuse Box
Petrol
| № | Circuit |
|---|---|
| 1 | Front wiper speed relay |
| 2 | ABS pump |
| 3 | Front wiper control relay |
| 4 | Front wiper |
| 5 | Blower |
| 6 | ABS valve |
| 7 | Sunroof |
| 8 | - |
| 9 | Rear wiper |
| 10 | RVC |
| 11 | ABS oil |
| 12 | AOS/ROS |
| 13 | OSRVM |
| 14 | Rear defog relay |
| 15 | Rear window defog |
| 16 | Spare fuse |
| 17 | Spare fuse |
| 18 | Spare fuse |
| 19 | Spare fuse |
| 20 | Spare fuse |
| 21 | Spare fuse |
| 22 | Spare fuse |
| 23 | - |
| 24 | RUN/CRANK IEC |
| 25 | RUN/CRANK relay |
| 26 | - |
| 27 | - |
| 28 | OSRVM HTD |
| 29 | - |
| 30 | Front seat heated |
| 31 | - |
| 32 | Flux fuel |
| 33 | Washer |
| 34 | Fuel pump relay |
| 35 | Fuel pump |
| 36 | ECM/TCM |
| 37 | - |
| 38 | - |
| 39 | Cool fan K5 |
| 40 | Cool fan K4 |
| 41 | EVP |
| 42 | ECM |
| 43 | AC clutch |
| 44 | TCM |
| 45 | ECM_1 |
| 46 | COIL |
| 47 | ECM_4 |
| 48 | ECM_3 |
| 49 | ECM_2 |
| 50 | Injector |
| 51 | P/T relay |
| 52 | Horn |
| 53 | Cool fan K3 relay |
| 54 | Start |
| 55 | Start relay |
| 56 | AC clutch relay |
| 57 | High beam relay |
| 58 | Front fog |
| 59 | High beam LH |
| 60 | High beam RH |
| 61 | Cool fan K1 relay |
Diesel
| № | Circuit |
|---|---|
| 1 | Front wiper speed relay |
| 2 | ABS pump |
| 3 | Front wiper control relay |
| 4 | Front wiper |
| 5 | Variable water pump power relay |
| 6 | Blower |
| 7 | Variable water pump power |
| 8 | OSRVM |
| 9 | AOS/ROS |
| 10 | ABS oil |
| 11 | RVC |
| 12 | Rear wiper |
| 13 | - |
| 14 | ABS valve |
| 15 | Sunroof |
| 16 | - |
| 17 | Rear defog relay |
| 18 | Rear window defog |
| 19-25 | Spare fuse |
| 26 | - |
| 27 | RUN/CRANK IEC |
| 28 | RUN/CRANK relay |
| 29 | Aux water pump power relay |
| 30 | Aux water pump power |
| 31 | OSRVM HTD |
| 32 | Fuel filter heater relay |
| 33 | Front seat heated |
| 34 | - |
| 35 | Washer |
| 37 | Fuel pump relay |
| 38 | Fuel pump |
| 39 | ECM/TCM |
| 40 | FSCM_2 |
| 41 | DC/DC Converter |
| 42 | Fuel filter heater |
| 43 | REC |
| 44 | Glow plug |
| 45 | ECM |
| 46 | AC clutch |
| 47 | TCM |
| 49 | ECM_1 |
| 50 | COIL |
| 51 | ECM_4 |
| 52 | ECM_3 |
| 53 | ECM_2 |
| 54 | Injector |
| 55 | Cool fan K2 relay |
| 56 | P/T relay |
| 57 | Cool fan K5 |
| 58 | Cool fan K4 |
| 59 | Cool fan K3 relay |
| 60 | Start |
| 61 | Start relay |
| 62 | AC clutch relay |
| 63 | High beam relay |
| 64 | Horn |
| 65 | Front fog |
| 66 | High beam LH |
| 67 | High beam RH |
| 68 | Cool fan K1 relay |
2014
Instrument Panel Fuse Box
| № | Circuit |
|---|---|
| 1 | DLIS |
| 2 | DLC |
| 3 | Airbag |
| 4 | Tail gate |
| 5 | Spare fuse |
| 6-13 | Body control module |
| 14 | IPC |
| 15 | ONSTAR |
| 16 | Ultra parking assist |
| 17 | Rain sensor |
| 18 | Audio |
| 19 | Trailer |
| 20 | VLBS / FCA / LDW |
| 21 | CHEVYSTAR |
| 22 | Heating, ventilation, air conditioning |
| 23 | HDLP ALC |
| 24 | Clutch |
| 25 | IPC-AOS |
| 26 | Airbag RUN/CRANK |
| 27 | Run relay |
| 28 | Tail gate relay |
| 29 | Trailer RUN/CRANK |
| 30 | Clock spring |
| 31 | Heating, ventilation, air conditioning |
| 32 | Spare fuse |
| 33 | Sunroof |
| 34 | Cigarette lighter |
| 35 | Spare fuse |
| 36 | Rear power window |
| 37 | Front power window |
| 38 | RAP/ACCY |
| 39 | DCDC CONV |
| 40 | Power window express up/down |
| 41 | PTC2 |
| 42 | PTC1 |
| 43 | Battery connector |
Engine Compartment Fuse Box
Petrol
| № | Circuit |
|---|---|
| 1 | Front wiper speed relay |
| 2 | ABS pump |
| 3 | Front wiper control relay |
| 4 | Front wiper |
| 5 | Blower |
| 6 | ABS valve |
| 7 | Sunroof |
| 9 | Rear wiper |
| 10 | RVC |
| 11 | ABS oil |
| 12 | AOS/ROS |
| 13 | OSRVM |
| 14 | Rear defog relay |
| 15 | Rear window defog |
| 16 | Spare fuse |
| 17 | Spare fuse |
| 18 | Spare fuse |
| 19 | Spare fuse |
| 20 | Spare fuse |
| 21 | Spare fuse |
| 22 | Spare fuse |
| 24 | RUN/CRANK IEC |
| 25 | RUN/CRANK relay |
| 28 | OSRVM HTD |
| 30 | Front seat heated |
| 31 | FSCM 1 |
| 32 | Flex fuel |
| 33 | Washer |
| 34 | Fuel pump relay |
| 35 | Fuel pump |
| 36 | ECM_5 |
| 37 | FSCM_2 / Levelling |
| 38 | TCM_1 |
| 39 | Cool fan K5 |
| 40 | Cool fan K4 |
| 41 | EVP |
| 42 | ECM |
| 43 | AC clutch |
| 44 | TCM |
| 45 | ECM_1 |
| 46 | COIL |
| 47 | ECM_4 |
| 48 | ECM_3 |
| 49 | ECM_2 |
| 50 | Injector / IG coil |
| 51 | P/T relay |
| 52 | Horn |
| 53 | Cool fan K3 relay |
| 54 | Start |
| 55 | Start relay |
| 56 | AC clutch relay |
| 57 | High beam relay |
| 58 | Front fog |
| 59 | High beam LH |
| 60 | High beam RH |
| 61 | Cool fan K1 relay |
Stop-start system vehicle
| № | Circuit |
|---|---|
| 1 | Front wiper |
| 2 | ABS pump |
| 3 | Front wiper control relay |
| 4 | Front wiper speed relay |
| 6 | Blower |
| 8 | OSRVM |
| 9 | AOS/ROS |
| 10 | ABS oil |
| 11 | RVC |
| 12 | Rear wiper |
| 13 | Not used/IBS |
| 14 | ABS valve |
| 15 | Sunroof |
| 17 | Rear defog relay |
| 18 | Rear window defog |
| 19-25 | Spare fuse |
| 27 | RUN/CRANK IEC |
| 28 | RUN/CRANK relay |
| 29 | Not used / SAI valve relay |
| 30 | Not used / SAI valve |
| 31 | OSRVM HTD |
| 32 | Aux water pump power relay |
| 33 | Front seat heated |
| 34 | FSCM_1 |
| 35 | Canister vent |
| 36 | Washer |
| 37 | Fuel pump relay |
| 38 | Fuel pump |
| 39 | ECM_5 |
| 40 | FSCM_2 / Levelling |
| 41 | TCM_1 / DC-DC Converter |
| 43 | SAI PUMP |
| 44 | EVP |
| 45 | ECM |
| 46 | AC clutch |
| 47 | TCM |
| 48 | Aux water pump power |
| 49 | ECM_1 |
| 50 | COIL |
| 51 | ECM_4 |
| 52 | ECM_3 |
| 53 | ECM_2 |
| 54 | Injector / IG coil |
| 55 | SAI pump relay |
| 56 | P/T relay |
| 57 | Cool fan K4 |
| 58 | Cool fan K5 |
| 59 | Cool fan K3 relay |
| 60 | Start |
| 61 | Start relay |
| 62 | AC clutch relay |
| 63 | High beam relay |
| 64 | Horn |
| 65 | Front fog |
| 66 | High beam LH |
| 67 | High beam RH |
| 68 | Cool fan K1 relay |
Diesel
| № | Circuit |
|---|---|
| 1 | Front wiper |
| 2 | ABS pump |
| 3 | Front wiper control relay |
| 4 | Front wiper speed relay |
| 6 | Blower |
| 8 | OSRVM |
| 9 | AOS/ROS |
| 10 | ABS oil |
| 11 | RVC |
| 12 | Rear wiper |
| 13 | Not used / IBS |
| 14 | ABS valve |
| 15 | Sunroof |
| 17 | Rear defog relay |
| 18 | Rear window defog |
| 19-25 | Spare fuse |
| 27 | RUN/CRANK IEC |
| 28 | RUN/CRANK relay |
| 29 | Aux water pump power relay |
| 30 | Aux water pump power |
| 31 | OSRVM HTD |
| 32 | Fuel filter heater relay |
| 33 | Front seat heated |
| 34 | Not used |
| 35 | Washer |
| 37 | Fuel pump relay |
| 38 | Fuel pump |
| 39 | ECM_5 |
| 40 | Levelling |
| 41 | DC-DC Converter |
| 42 | Fuel filter heater |
| 44 | Glow plug |
| 45 | ECM |
| 46 | AC clutch |
| 47 | TCM |
| 49 | ECM_1 |
| 50 | COIL |
| 51 | ECM_4 |
| 52 | ECM_3 |
| 53 | ECM_2 |
| 54 | PCV heater |
| 55 | Cool fan K2 relay |
| 56 | P/T relay |
| 57 | Cool fan K5 |
| 58 | Cool fan K4 |
| 59 | Cool fan K3 relay |
| 60 | Start |
| 61 | Start relay |
| 62 | AC clutch relay |
| 63 | High beam relay |
| 64 | Horn |
| 65 | Front fog |
| 66 | High beam LH |
| 67 | High beam RH |
| 68 | Cool fan K1 relay |