Page Contents:
In this article, you will find information about the fuses of the Ford Expedition (models 2007 and 2008), including diagrams of the fuse boxes, a list of fuses and relays, their designation, and the location of the fuse blocks within the vehicle.
Checking and Replacing Fuses in Ford Expedition
If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components.
Caution!
- Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
- Always disconnect the battery before servicing high current fuses.
- To reduce risk of electrical shock, always replace the cover to the Power Distribution Box before reconnecting the battery or refilling fluid reservoirs.
Location of Fuse Boxes
Passenger Compartment Fuse Panel:
The fuse panel is located under the right-hand side of the instrument panel. To remove the trim panel for access to the fuse box, pull the panel toward you and swing it out away from the side and remove it. To reinstall it, line up the tabs with the grooves on the panel, then push it shut.
To remove the fuse box cover, press in the tabs on both sides of the cover, then pull the cover off. To reinstall the fuse box cover, place the top part of the cover on the fuse panel, then push the bottom part of the cover until you hear it click shut. Gently pull on the cover to make sure it is seated properly.
Power Distribution Box:
The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
Fuse Box Diagrams
2007
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | 30A | Smart window #1 |
| 2 | 15A | Driver side memory module |
| 3 | 15A | FES, Audio rear seat Controls, SDARS |
| 4 | 30A | Smart window #2 |
| 5 | 10A | Keypad illumination, 3rd row seat enable, Brake Shift Interlock (BSI), SPDJB |
| 6 | 20A | Turn signals |
| 7 | 10A | Low beam headlamps (left) |
| 8 | 10A | Low beam headlamps (right) |
| 9 | 15A | Interior lights |
| 10 | 15A | Backlighting, Puddle lamps |
| 11 | - | Not used |
| 12 | 7.5A | Power mirror switch, Driver seat memory switch |
| 13 | - | Not used |
| 14 | 10A | Power liftgate module - keep-alive power |
| 15 | 10A | Climate control |
| 16 | - | Not used |
| 17 | 20A | All lock motor feeds, Liftgate release, Liftglass release |
| 18 | 20A | Not used (Spare) |
| 19 | 25A | Rear wiper |
| 20 | 15A | Adjustable pedais, Datalink |
| 21 | 15A | Fog lamps, Cornering lamps |
| 22 | 15A | Park lamps relay |
| 23 | 15A | High beam headlamps |
| 24 | 20A | Horn relay |
| 25 | 10A | Demand lamps, Glovebox, Visor |
| 26 | 10A | Instmment panel cluster |
| 27 | 20A | Ignition switch |
| 28 | 5A | Radio |
| 29 | 5A | Instmment panel cluster |
| 30 | 5A | Not used (Spare) |
| 31 | 10A | Compass, Automatic dimming rear view mirror |
| 32 | 10A | Restraints control module |
| 33 | - | Not used |
| 34 | 5A | Not used (spare) |
| 35 | 10A | Rear park assist, 4x4 |
| 36 | 5A | PATS transceiver |
| 37 | 10A | Climate control |
| 38 | 20A | Subwoofer/Amp (Audiophile radio) |
| 39 | 20A | Radio |
| 40 | - | Not used |
| 41 | - | Not used |
| 42 | 10A | Trailer tow battery charge coil |
| 43 | 10A | Rear wiper logic |
| 44 | - | Not used |
| 45 | 5A | Front wiper logic |
| 46 | 7.5A | Climate control, Auxiliary relay control |
| 47 | 30A Circuit Breaker | Power Windows, Moon roof |
| 48 | - | Delayed accessory relay |
Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | - | Blower relay |
| 2 | - | Not used |
| 3 | - | Rear window defroster relay |
| 4 | 30A** | Third row seats (driver side) |
| 5 | 40A** | Trailer tow connector (electric brake) |
| 6 | 60A** | ABS (valves) |
| 7 | - | Not used |
| 8 | 40A** | Heated/cooled seats |
| 9 | 60A** | ABS (pump) |
| 10 | 20A** | Rear console power point |
| 11 | 30A** | Auxiliary blower |
| 12 | 25A* | Trailer tow connector (park lamps) |
| 13 | 30A * | Trailer tow connector (battery charge) |
| 14 | - | Not used |
| 15 | - | Not used |
| 16 | - | A/C clutch relay |
| 17 | - | Not used |
| 18 | - | Fuel pump relay |
| 19 | - | Back-up relay |
| 20 | - | Trailer tow connector relay (left turn signal) |
| 21 | - | Trailer tow connector relay (right turn signal) |
| 22 | - | Not used |
| 23 | 15A* | Heated mirrors |
| 24 | 40A** | Blower motor |
| 25 | - | Not used |
| 26 | - | Not used |
| 27 | 30A** | Power liftgate |
| 28 | 40A** | Rear window defroster, Heated mirror |
| 29 | 30A** | Passenger seat |
| 30 | 10A* | A/C clutch |
| 31 | 15A* | Brake lamps |
| 32 | 20A* | Fuel pump |
| 33 | 20A* | Back-up lamps |
| 34 | 25A* | Trailer tow connector (stop/turn lamps) |
| 35 | 20A* | 4x4 module |
| 36 | 10A* | Powertrain Control Module (PCM) - Keep alive power, Canister vent |
| 37 | 15A* | Transmission B+ |
| 38 | 30A** | Third row seats (passenger side) |
| 39 | 50A** | Air suspension pump |
| 40 | 30A** | Starter motor |
| 41 | 20A** | IP/Console power point |
| 42 | - | Not used |
| 43 | 20A** | 4x4 module motor |
| 44 | - | Not used |
| 45 | 30A** | Driver seat |
| 46 | 40A** | Run/Start bus bar |
| 47 | 30A** | Air suspension - solenoids |
| 48 | - | Not used |
| 49 | 30A** | Front wipers/washer |
| 50 | 30A** | PCM - bus bar |
| 51 | 20A** | Cargo power point |
| 52 | 20A** | Cigarette lighter |
| 53 | - | Air suspension relay |
| 54 | - | Starter relay |
| 55 | - | Trailer tow connector relay (park lamp) |
| 56 | - | Trailer tow connector relay (battery charge) |
| 57 | - | Run/Start relay |
| 58 | - | Not used |
| 59 | - | PCM relay |
| 60 | - | One-touch Start diode |
| 61 | - | A/C clutch diode |
| 62 | - | Fuel pump diode |
| 63 | 15A* | Trailer tow connector (back-up lamp) |
| 64 | - | Not used |
| 65 | 10A* | Air suspension logic |
| 66 | - | Not used |
| 67 | 10A* | Blower coil |
| 68 | - | Not used |
| 69 | 30A* | Run/Start - passenger compartment fuse panel |
| 70 | 20A* | PCM (sensors) - EFC, A/C clutch coil |
| 71 | 5A* | Fuel coil, ISP-R |
| 72 | 20A* | PCM (ignition coils) |
| 73 | 5A* | Transmission ignition |
| 74 | 20A* | PCM (sensors) - HEGO/CMS, MAFS, EVMV, CMCV, Speed deactivation switch, VCT |
| 75 | 5A* | 4x4 Integrated Wheel Ends (IWE) solenoid |
| 76 | 20A* | PCM - VPWR |
| 77 | 10A* | ABS logic, Heated PCV |
| * Mini Fuses ** Cartridge Fuses | ||
2008
Passenger Compartment Fuse Panel
| № | A | Description |
|---|---|---|
| 1 | 30A | Smart window #1 |
| 2 | 15A | Driver side memory module |
| 3 | 15A | FES, Audio rear seat Controls, SDARS |
| 4 | 30A | Smart window #2 |
| 5 | 10A | Keypad illumination, 3rd row seat enable, Brake Shift Interlock (BSI), SPDJB |
| 6 | 20A | Turn signals |
| 7 | 10A | Low beam headlamps (left) |
| 8 | 10A | Low beam headlamps (right) |
| 9 | 15A | Interior lights |
| 10 | 15A | Backlighting, Puddle lamps |
| 11 | 10A | Not used (Spare) |
| 12 | 7.5A | Power mirror switch, Driver seat memory switch |
| 13 | 7.5A | Not used (Spare) |
| 14 | 10A | Power liftgate module - keep-alive power |
| 15 | 10A | Climate control |
| 16 | 15A | Not used (Spare) |
| 17 | 20A | All lock motor feeds, Liftgate release, Liftglass release |
| 18 | 20A | Not used (Spare) |
| 19 | 25A | Rear wiper |
| 20 | 15A | Adjustable pedais, Datalink |
| 21 | 15A | Fog lamps, Cornering lamps |
| 22 | 15A | Park lamps relay |
| 23 | 15A | High beam headlamps |
| 24 | 20A | Horn relay |
| 25 | 10A | Demand lamps, Glovebox, Visor |
| 26 | 10A | Instmment panel cluster |
| 27 | 20A | Ignition switch |
| 28 | 5A | Radio |
| 29 | 5A | Instmment panel cluster |
| 30 | 5A | Not used (Spare) |
| 31 | 10A | Compass, Automatic dimming rear view mirror |
| 32 | 10A | Restraints control module |
| 33 | 10A | Not used (Spare) |
| 34 | 5A | Not used (Spare) |
| 35 | 10A | Rear park assist, 4x4, rear video camera |
| 36 | 5A | PATS transceiver |
| 37 | 10A | Climate control |
| 38 | 20A | Subwoofer/Amp (Audiophile radio) |
| 39 | 20A | Radio |
| 40 | 20A | Not used (Spare) |
| 41 | 15A | Not used (Spare) |
| 42 | 10A | Trailer tow battery charge coil |
| 43 | 10A | Rear wiper logic |
| 44 | 10A | Not used (Spare) |
| 45 | 5A | Front wiper logic |
| 46 | 7.5A | Climate control, Auxiliary relay control |
| 47 | 30A Circuit Breaker | Power Windows, Moon roof |
| 48 | - | Delayed accessory relay |
Power Distribution Box
| № | A | Description |
|---|---|---|
| 1 | - | Blower relay |
| 2 | - | Not used |
| 3 | - | Rear window defroster relay |
| 4 | 30A** | Third row seats (driver side) |
| 5 | 30A** | Trailer tow connector (electric brake) |
| 6 | 60A** | ABS (valves) |
| 7 | - | Not used |
| 8 | 40A** | Heated/cooled seats |
| 9 | 60A** | ABS (pump) |
| 10 | 20A** | Rear console power point |
| 11 | 30A** | Auxiliary blower |
| 12 | 25A* | Trailer tow connector (park lamps) |
| 13 | 30A* | Trailer tow connector (battery charge) |
| 14 | - | Not used |
| 15 | - | Not used |
| 16 | - | A/C clutch relay |
| 17 | - | Not used |
| 18 | - | Fuel pump relay |
| 19 | - | Back-up relay |
| 20 | - | Trailer tow connector relay (left turn signal) |
| 21 | - | Trailer tow connector relay (right turn signal) |
| 22 | - | Not used |
| 23 | 15A* | Heated mirrors |
| 24 | 40A** | Blower motor |
| 25 | - | Not used |
| 26 | - | Not used |
| 27 | 30A** | Power liftgate |
| 28 | 40A** | Rear window defroster, Heated mirror |
| 29 | 30A** | Passenger seat |
| 30 | 10A* | A/C clutch |
| 31 | 15A* | Brake lamps |
| 32 | 20A* | Fuel pump |
| 33 | 20A* | Back-up lamps |
| 34 | 25A* | Trailer tow connector (stop/turn lamps) |
| 35 | 20A* | 4x4 module |
| 36 | 10A* | Powertrain Control Module (PCM) - Keep alive power, Canister vent |
| 37 | 15A* | Transmission B+ |
| 38 | 30A** | Third row seats (passenger side) |
| 39 | 60A** | Air suspension pump |
| 40 | 30A** | Starter motor |
| 41 | 20A** | IP/Console power point |
| 42 | - | Not used |
| 43 | 20A** | 4x4 module motor |
| 44 | - | Not used |
| 45 | 30A** | Driver seat |
| 46 | 40A** | Run/Start bus bar |
| 47 | 30A** | Air suspension - solenoids |
| 48 | - | Not used |
| 49 | 30A** | Front wipers/washer |
| 50 | 30A** | PCM - bus bar |
| 51 | 20A** | Cargo power point |
| 52 | 20A** | Cigarette lighter |
| 53 | - | Air suspension relay |
| 54 | - | Starter relay |
| 55 | - | Trailer tow connector relay (park lamp) |
| 56 | - | Trailer tow connector relay (battery charge) |
| 57 | - | Run/Start relay |
| 58 | - | Not used |
| 59 | - | PCM relay |
| 60 | - | One-touch Start diode |
| 61 | - | Not used |
| 62 | - | Fuel pump diode |
| 63 | 15A* | Trailer tow connector (back-up lamp) |
| 64 | - | Not used |
| 65 | 10A* | Air suspension logic |
| 66 | - | Not used |
| 67 | 10A* | Blower coil |
| 68 | - | Not used |
| 69 | 30A* | Run/Start - passenger compartment fuse panel |
| 70 | 20A* | PCM (sensors) - EFC, A/C clutch coil |
| 71 | 5A* | Fuel coil, ISP-R |
| 72 | 20A* | PCM (ignition coils) |
| 73 | 5A* | Transmission ignition |
| 74 | 20A* | PCM (sensors) - HEGO/CMS, MAFS, EVMV, CMCV, Speed deactivation switch, VCT |
| 75 | 5A* | 4x4 Integrated Wheel Ends (IWE) solenoid |
| 76 | 20A* | PCM - VPWR |
| 77 | 10A* | ABS logic, Heated PCY |
| * Mini Fuses ** Cartridge Fuses | ||